Email updates

Keep up to date with the latest news and content from BMC Biotechnology and BioMed Central.

Open Access Research article

Production of 3,4-dihydroxy L-phenylalanine by a newly isolated Aspergillus niger and parameter significance analysis by Plackett-Burman design

S Ali* and I Haq

Author Affiliations

Institute of Industrial Biotechnology (IIB), GC University Lahore, Lahore-54000, Pakistan

For all author emails, please log on.

BMC Biotechnology 2010, 10:86  doi:10.1186/1472-6750-10-86


The electronic version of this article is the complete one and can be found online at: http://www.biomedcentral.com/1472-6750/10/86


Received:19 June 2010
Accepted:10 December 2010
Published:10 December 2010

© 2010 Ali and Haq; licensee BioMed Central Ltd.

This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract

Background

The amino acid derivative 3,4-dihydroxy L-phenylalanine (L-dopa) is gaining interest as a drug of choice for Parkinson's disease. Aspergillus oryzae is commonly used for L-dopa production; however, a slower growth rate and relatively lower tyrosinase activity of mycelia have led to an increasing interest in exploiting alternative fungal cultures. In the present investigation, we report on the microbiological transformation of L-tyrosine to L-dopa accomplished by a newly isolated filamentous fungus Aspergillus niger.

Results

The culture A. niger (isolate GCBT-8) was propagated in 500 ml Erlenmeyer flasks and the pre-grown mycelia (48 h old) were used in the reaction mixture as a source of enzyme tyrosinase. Grinded mycelia gave 1.26 fold higher L-dopa production compared to the intact at 6% glucose (pH 5.5). The rate of L-tyrosine consumption was improved from 0.198 to 0.281 mg/ml. Among the various nitrogen sources, 1.5% peptone, 1% yeast extract and 0.2% ammonium chloride were optimized. The maximal L-dopa was produced (0.365 mg/ml) at 0.3% potassium dihydrogen phosphate with L-tyrosine consumption of 0.403 mg/ml.

Conclusion

Over ~73% yield was achieved (degree of freedom 3) when the process parameters were identified using 2k-Plackett-Burman experimental design. The results are highly significant (p ≤ 0.05) and mark the commercial utility (LSD 0.016) of the mould culture which is perhaps the first ever report on L-dopa production from A. niger.

Background

The 3,4-dihydroxy L-phenylalanine (L-dopa) is known to be produced from L-tyrosine by a one-step oxidation reaction under submerged batch culture [1]. The optimisation of cultural conditions is necessary for a successful cultivation process. The key enzyme responsible for biosynthesis of L-dopa is tyrosinase [2]. Tyrosinases are widely distributed and highly purified enzymes, derived from microbial (Aspergillus, Rhizopus and Neurospora spp.) or plant sources (Agaricus and Vicia spp.). However in microorganisms, enzyme activity is generally very weak; L-tyrosine along with L-dopa is rapidly decomposed to other metabolites. Thus, stoichiometric formation of L-dopa is difficult to achieve [3,4]. In addition, L-dopa is an unstable product in the reaction mixture and is further converted into dopaquinone and the final product melanin [5]. Because of the higher production cost and its greater commercial value, many researchers have investigated on the alternative production of L-dopa [6,7]. Investigations have now centred upon microbiological L-dopa production from Erwinia herbicola and Escherichia coli [8,9]. However, the production could be expensive due to the removal of proteins and hormones which would also be produced by the microbial cells. Another alternative method is the L-dopa production from L-tyrosine with an immobilized tyrosinase. The enzyme inhibits below pH 3.5 and thus decreases L-dopa production [10]. The optimal production was obtained when glucose was used as a carbon source [11,12]. The nitrogen sources as well as the concentration of nitrogen containing salts, sucrose and phosphate in the culture medium were found to greatly affect the biosynthetic pathway of L-dopa [13].

Aspergillus oryzae has largely been exploited as an organism of choice for L-dopa production; however its use has been limited drastically due to the strong tyrosinase inhibitors produced by the pre-grown mycelia [14]. In addition, a much slower growth rate of this fungus has urged to find a better alternative microorganism [5,15]. Therefore, in the present study, different strains of A. niger were isolated from bread wastes. Among them isolate GCBT-8 was found to be a faster growing culture and gave the highest product yield. An increase in biomass of this mould culture was attempted to further enhance L-dopa production under submerged cultivation. As tyrosinase is an intracellular enzyme, so mould mycelia were used for the biochemical conversion of L-tyrosine to L-dopa. The 2-factorial Plackett-Burman experimental design was used to further identify the significant variables influencing L-dopa production.

Methods

Maintenance of A. niger

Various strains of A. niger were isolated from bread wastes by pour plate method [5]. The samples were collected in sterilized polythene bags from the local market of Lahore (Pakistan). The strains were maintained on potato dextrose agar (PDA) medium, pH 5.6 and incubated at 30°C for 4-6 days until maximal sporulation. Preliminary screening of fungal isolates was accomplished using PDA medium containing 0.1% L-tyrosine as an inducer and bromocresol green dye as an indicator [5].

Inoculum Preparation

The spore suspension was prepared by adding 10 ml of sterilized distilled water aseptically to a 4-6 day old slant culture having profuse growth on its surface. An inoculum needle was used to disrupt the clumps of spores. The tube was shaken gently to form a homogeneous suspension. The spore count was made on a haemocytometer.

Propagation, Harvesting and Ultrasonication of Fungal Mycelia

The propagation of mycelia was carried out by taking 100 ml of medium containing 4 g/l glucose, 2 g/l peptone, 0.6 g/l NH4Cl, 0.6 g/l KH2PO4, 0.04 g/l MgSO4.7H2O, 2 g/l yeast extract at pH 5 in 500 ml Erlenmeyer flasks. The flasks were cotton plugged and sterilized in an autoclave at 15 lbs/in2 pressure (121°C) for 20 min. The medium was inoculated with 5 ml of spore suspension (1.45×106 CFU/ml) of A. niger. The flasks were incubated at 30°C for 48 h in a rotary shaker (350 rpm). The mycelia were harvested by filtering through a funnel and washed free of adhering medium with ice cold water (4°C). These intact mycelia were dried in filter paper folds. The grinded form of mycelia was obtained after disrupting them by an ultrasonicator for 5 min [12]. Both the intact and grinded mycelia were stored at 4°C in a cold cabinet. All the experiments were run parallel in triplicates.

Reaction Procedure and Critical Phases

The reaction for L-dopa production from L-tyrosine was carried out in a suspension of intact fungal mycelia [1]. The reaction mixture was prepared by adding 0.0625 g/l L-tyrosine, 1.875 g/l mycelia (intact or grinded), 0.125 g/l L-ascorbic acid in 50 mM acetate buffer (pH 3.5). Twenty five millilitre of this reaction mixture was taken in 250 ml Erlenmeyer flasks. The reactions were performed aerobically at 50°C for 60 min in a shaking water bath (240 rpm).

Analytical Techniques

The sample was withdrawn and centrifuged at 9000×g for 15 min. The supernatant was used for analysis of L-dopa produced and L-tyrosine consumed in the reaction mixture following the analytical methods of Arnow [16].

Estimation of L-Tyrosine

One millilitre of supernatant from the reaction mixture along with 1 ml of mercuric sulphate reagent was taken in a test tube. The tube was placed in a boiling water bath for 10 min. The assay mixture was cooled and 1 ml of nitrite reagent was added. The volume was raised upto 16 ml with distilled water. The diluted mixture was analyzed (A550 nm) by a spectrophotometer and the amount of residual L-tyrosine was determined after comparing with the tyrosine-standard.

Estimation of L-Dopa

One millilitre of supernatant from the reaction mixture was taken in a test tube. Then 1 ml of 0.5N HCl along with 1 ml of nitrite molybdate reagent was added to it. A yellow colour appeared. One millilitre of 1N NaOH was also added which gave a red coloration. The volume was raised upto 16 ml with distilled water. The diluted mixture was analyzed (A550 nm) by a spectrophotometer and the amount of produced L-dopa was determined after comparing with the dopa-standard. All preparations of L-dopa were also examined by infrared spectroscopy and further confirmed by paper chromatography [6]. The chromatography was performed on a Whatman filter paper (No. 1) using l-butanolacetic acid-distilled water (4:1, v/v) as a solvent. The chromatograms were developed with a equal volume mixture of 20 mM NaH2PO4, 50 mM acetonitrile and 35 mm L-catechol. Figure 1 shows a paper chromatogram, run for the separation of L-dopa fraction from residual L-tyrosine and other intermediates.

thumbnailFigure 1. Separation of L-dopa fractions from eight different samples of the reaction mixture run on paper chromatogram.

Determination of Tyrosinase Activity

Tyrosinase activity was determined after Kandaswami and Vaidyanathan [17]. One unit of enzyme activity is equal to a ΔA265 nm of 0.001 per min at pH 6.5 (25°C) in a 3 ml reaction mixture containing L-catechol and L-ascorbic acid. For this, 2.6 ml of 50 mM potassium phosphate buffer along with 0.1 ml L-catechol, 0.1 ml L-ascorbic acid and 0.1 ml EDTA were mixed by inversion and equilibrated to 25°C. The ΔA265 nm was monitored until constant, followed by the addition of 100 μl of reaction broth. The decrease in ΔA265 nm was recorded for 5 min with an equal interval of 1 min. The ΔA265 nm was obtained using the maximal linear rate for both the test and control. Enzyme activity was determined using the following formula,

<a onClick="popup('http://www.biomedcentral.com/1472-6750/10/86/mathml/M1','MathML',630,470);return false;" target="_blank" href="http://www.biomedcentral.com/1472-6750/10/86/mathml/M1">View MathML</a>

Kinetic Depiction

The kinetic parameters for L-dopa production and L-tyrosine consumption were studied according to the procedures of Pirt [18]. The volumetric rates for substrate utilization (Qs mg/ml/min) and product formation (Qp mg/ml/min) were determined from the maximum slopes in plots of substrate utilized and L-dopa produced each vs. the time of reaction. The product yield coefficient Yp/s was determined using the relationship i.e., Yp/s = dP/dS (mg/ml). The specific rate constants for product formation (qp mg/mg cells/min) and substrate utilization (qs mg/mg cells/min) were determined by the equations i.e., qp = μ×Yp/x and qs = μ×Ys/x, respectively.

Statistical Analysis and Application of 2k-Factorial Design

Duncan's multiple range tests (Spss-16, version 11.5) were applied under one-way analysis of variance (I-ANOVA) and the treatment effects were compared according to Snedecor and Cochran [19]. Significance is presented in the form of probability (p ≤ 0.05) values. The significant variables were identified using a 2k-factorial system i.e., Plackett-Burman experimental design [20]. The variables were denoted at two widely spaced intervals and the effect of individual parameters on L-dopa production was calculated by the following equations,

<a onClick="popup('http://www.biomedcentral.com/1472-6750/10/86/mathml/M2','MathML',630,470);return false;" target="_blank" href="http://www.biomedcentral.com/1472-6750/10/86/mathml/M2">View MathML</a>

(I)

<a onClick="popup('http://www.biomedcentral.com/1472-6750/10/86/mathml/M3','MathML',630,470);return false;" target="_blank" href="http://www.biomedcentral.com/1472-6750/10/86/mathml/M3">View MathML</a>

(II)

In Eq. I, Eο is the effect of first parameter under study while M+ and M- are responses of L-dopa production by the filamentous fungus. N is the total number of optimizations. In Eq. II, E is the significant parameter, β1 is the linear coefficient, β2 the quadratic coefficient and β3 is the interaction coefficient for process parameters.

Results and Discussion

Screening of Fungal Cultures for L-Dopa Production

In the present study, several strains of A. niger were isolated from bread wastes by serial dilution method. Initially fungal isolates were screened on the basis of larger reddish zones of L-tyrosine hydrolysis in the growth medium, indicated by the presence of bromocresol green dye. Among them, isolate GCBT-8 was found to be a faster growing culture and gave the highest product yield. An increase in biomass of this mould culture was attempted to further enhance L-dopa production under submerged cultivation. Initially, the culture (strain GCBT-8) was used for the propagation of mycelia in 500 ml Erlenmeyer flasks for L-dopa production. The fungus A. niger GCBT-8 is capable of producing tyrosinase with activity 43.28 U/mg in an acidic reaction mixture which transformed tyrosine and its derivatives to L-dopa as reported by Krishnaveni et al. [21]. The fungal strain was grown in a medium containing carbon sources, nitrogen sources, minerals, and other essential nutrients. To obtain optimal yield of L-dopa, it was imperative to add L-ascorbic acid in the reaction broth to prevent melanin formation. Since tyrosinase appears to be an inducible enzyme, its activity should be optimally increased to convert more L-tyrosine into L-dopa [13,22].

Propagation of A. niger Mycelia

The maximum amount of L-dopa (0.1533 mg/ml) was produced when 48 h old mycelia were used in the reaction mixture as a source of enzyme tyrosinase (Figure 2). It was due to the increased tyrosinase activity of A. niger mycelia. A further increase in the time of mycelial propagation greatly reduced L-tyrosine consumption and subsequent L-dopa production possibly due to the conversion of L-dopa into other metabolites such as dopamine or dopachrome. The change in colour from red to black was due to the formation of melanin like substances in the reaction broth [23,24]. In the present study, at 96-120 h of propagation time, L-dopa production declined from 0.0263 to 0.173 mg/ml. Mason [25] reported that L-dopa production remained low in a short propagation period viz-a-viz a prolonged propagation time for mycelial cultivation greatly reduced L-dopa production. Melanosine and melanin were also produced in the reaction mixture but their highest volumetric productivities remained 0.015 and 0.0026 mg/ml, respectively.

thumbnailFigure 2. Propagation of A. niger GCBT-8 for L-dopa production. Glucose conc. 6% (w/v), initial pH 5. Standard bars indicate standard deviation (± sd) among the three parallel replicates (L-tyrosine consumed - × -, L-dopa produced - ○ -).

Effect of Initial pH

Initial pH has a profound effect on the bioconversion of L-tyrosine to L-dopa. The maximum L-dopa production (0.153 mg/ml) and consumption of L-tyrosine (0.186 mg/ml) was observed when pH of the cultivation medium was adjusted to 5.5 (Figure 3). It was due to the optimal growth of fungal mycelia because metabolic pathways were operating normally at this pH. The enzymes produced including tyrosinase, tyrosine hydroxylase and β-tyrosinase were also in their highest concentrations. These enzymes catalyzed the oxidation of tyrosine to a greater extent and a higher amount of L-dopa was thus produced in the reaction mixture. In a similar study, Haneda et al. [1] obtained maximum L-dopa production (0.084 mg/ml), when pH of the medium was adjusted to 5 rather at 5.5. A further increase in the pH of the medium other than the optimal greatly reduced both L-tyrosine consumption and L-dopa production. At pH ranging from 6-6.5 of the medium, L-dopa production declined from 0.147 to 0.0693 mg/ml due to the disturbed fungal physiology and tyrosinase depletion. However, Evan and Raper [26] reported the limits of tyrosinase activity at a broad pH range (5-10).

thumbnailFigure 3. Effect of different initial pH on the propagation of A. niger GCBT-8 for L-dopa production. Glucose conc. 6% (w/v), propagation time 48 h. Standard bars indicate standard deviation (± sd) among the three parallel replicates (L-tyrosine consumed - × -, L-dopa produced - ○ -).

Role of Intact and Grinded Mycelia Developed at Various Glucose Concentrations

As tyrosinase is an intracellular enzyme, so mould mycelia were used for the biochemical conversion of L-tyrosine to L-dopa. A comparison for the effect of glucose concentration on the propagation of A. niger (intact and grinded mycelia) was made at glucose concentration ranging from 2-12% (w/v) for each set (Figure 4a & 4b). L-Dopa production increased gradually from 2-6%. However, maximal L-dopa production (0.2183 mg/ml) was obtained with the grinded mycelia when 6% glucose as a basal carbon source was supplemented to the medium. The enzyme tyrosinase was restricted in the intact cells and didn't release into the reaction mixture. However in case of grinded mycelia, tyrosinase released into the reaction mixture catabolized the available L-tyrosine, hence resulted in the maximal L-dopa production. The consumption of L-tyrosine was recorded to be 0.281 mg/ml at the optimal glucose level. A gradual reduction in L-dopa production was observed with both the intact and grinded mycelia when glucose concentration was further increased other than the optimal. It was due to the accumulation of other derivatives like dopamine, dopaquinone or dopachrome. These results were substantiated with the findings reported by Sarin et al. [27] and Lee et al. [28]. An insignificant amount of L-dopa production (0.076 mg/ml) was however obtained with the intact mycelia at 12% glucose. L-tyrosine consumption was found to be 0.104 mg/ml. Therefore, grinded mycelia gave 1.26 fold higher L-dopa production compared to the intact at a glucose level of 6%.

thumbnailFigure 4. Effect of glucose levels on the propagation of A. niger GCBT-8 for L-dopa production. a) Intact mycelia, b) Grinded mycelia. Propagation time 48 h, initial pH 5.5. Standard bars indicate standard deviation (± sd) among the three parallel replicates (L-tyrosine consumed - × -, L-dopa produced - ○ -).

Evaluation of Nitrogen Sources

The nitrogen source as well as its concentration in the cultivation medium greatly affects the biosynthesis of L-dopa from L-tyrosine. The optimal level of L-dopa production with 1.5% (w/v) peptone (0.265 mg/ml) and 1% (w/v) yeast extract (0.264 mg/ml) as organic nitrogen sources was recorded. The level of L-tyrosine consumption was noted to be 0.224 and 0.308 mg/ml, respectively (Figure 5a and 5b). L-Dopa production was however, declined when 0.5% (w/v) peptone (0.163 mg/ml) or 2% yeast extract (0.14 mg/ml) were added into the cultivation medium. It was due to the rapid biotransformation of tyrosine into L-dopa and then to dopachrome or indol-5,6-quinone. The final product was melanin with other pigmented intermediates as reported earlier [15,29,30]. Similar kinds of findings have also been reported by Huang et al. [31]. L-Dopa can be produced with higher efficiency using ammonium chloride as an inorganic nitrogen source. The maximum production (0.306 mg/ml) was observed at 0.2% ammonium chloride (Figure 5c). It was found optimal as tyrosinase activity was increased; hence a higher rate of L-dopa production was observed. A decreased level of L-dopa production (0.131 mg/ml) was possibly due to the lower mycelial growth which was not enough to oxidize L-tyrosine into L-dopa completely. L-Dopa production was almost doubled compared to other ammonium salts used solely in the medium. When ammonium chloride was used as source of ammonium ion, β-tyrosinase activity was more than 1.62 fold higher than that obtained with other sources of ammonium. The maximum L-dopa (0.134 mg/ml with 0.428 mg/ml L-tyrosine consumption) was achieved at 4% level of the optimal nitrogen source used [13].

thumbnailFigure 5. Evaluation of nitrogen sources for the propagation of A. niger GCBT-8 for L-dopa production. a) Peptone, b) Yeast extract, c) ammonium chloride. Glucose conc. 6% (w/v), propagation time 48 h, initial pH 5.5. Standard bars indicate standard deviation (± sd) among the three parallel replicates (L-tyrosine consumed - × -, L-dopa produced - ○ -).

Evaluation of Potassium Sources

The effect of potassium sources viz. potassium dihydrogen phosphate and dipotassium hydrogen phosphate for L-dopa production from L-tyrosine in the reaction mixture by A. niger was also investigated. The concentration was ranged from 0.1 to 0.8 mg/ml for each trial (Figure 6a & 6b). The maximum L-dopa production (0.365 mg/ml) was obtained at 0.3% (w/v) potassium dihydrogen phosphate with L-tyrosine consumption of 0.403 mg/ml. L-Dopa production was gradually decreased at higher concentrations of potassium dihydrogen phosphate other than 0.3%. The production declined to 0.253 mg/ml when 0.8% potassium dihydrogen phosphate was added into the cultivation medium. Potassium helped the mycelial cells to grow faster with a much better vigour. This element also produced a fluffy mass of mycelia which liberated the enzyme tyosinase in larger quantities when treated in L-ascorbate acidulated reaction broth as reported by Kuo et al. [32]. The addition of dipotassium hydrogen phosphate was, however not found significant for both L-tyrosine consumption and L-dopa production at all the rates examined. The level of product formation (0.047-0.164 mg/ml with a decreased rate of substrate consumption from 0.023 to 0.176 mg/ml) remained all the way less compared to the lowest concentration of potassium dihydrogen phosphate (0.212 mg/ml L-dopa at 0.1%).

thumbnailFigure 6. Evaluation of potassium sources for the propagation of A. niger GCBT-8 for L-dopa production. a) Dipotassium hydrogen phosphate conc., b) Potassium dihydrogen phosphate conc. Glucose conc. 6% (w/v), propagation time 48 h, initial pH 5.5. Standard bars indicate standard deviation (± sd) among the three parallel replicates which differ significantly at p ≤ 0.05 (L-tyrosine consumed - × -, L-dopa produced - ○ -).

Kinetic Study

The kinetic variables notably product formation parameters (Qp, Yp/s, qp) and substrate consumption parameters (Qs, qs) by A. niger GCBT-8 were compared for intact and grinded mycelia as sources of enzyme tyrosinase, β-carboxylase or tyrosine hydroxylase (Table 1). The comparison of Qp (mg/ml/min) for L-dopa productivity demonstrated that the grinded mycelia have a higher value for volumetric rate of product formation (0.0061 mg/ml/min) than the intact mycelia. Several fold improvement in terms of volumetric productivity was noted with the grinded mycelia at all the rates examined. In addition, when both of the mycelia were monitored for specific rate constant, the former gave relatively higher values for qp than the use of intact mycelia in the reaction mixture. The grinded mycelia exhibited an overall 4-6 fold improvement in the values for Qp, Yp/s and qp compared to the intact (LSD 0.016) which is highly significant (HS, p ≤ 0.05) and it was further supported by the findings reported by Pirt [18]. Haq et al. [15] found that nutritional parameters influence the substrate consumption rate, specific growth and subsequent productivity of tyrosinases. It is evident from the kinetic values that the enzymes are intracellular rather than extracellular and these have higher affinity for tyrosine as a substrate compared to other amino acids or derivatives of L-tyrosine. Haq and Ali [7] attempted to hyper produce L-dopa by 0.16 μg vermiculite addition during reaction and achieved 0.055 mg/ml of the actual product required. In the present study, maximum Yp/s, Qp and qp were several-fold improved over those from some other Aspergillus or Cellulomonas spp. [12]. As L-dopa is a high cost but low yield product; the maximal L-dopa production from the amino acid i.e., L-tyrosine was attributed to the medium composition, cultivation design, tonicity of the reaction broth and mycelial morphology of the culture used [4,18].

Table 1. Comparison of kinetic variables for propagation of A. niger GCBT-8 for L-dopa production

Application of 2k-Plackett-Burman Design

A two way factorial experimental method i.e., 2k-Plackett-Burman design was applied to determine the significant process parameters for L-dopa production by A. niger GCBT-8. The data are given in Table 2. The validation of the model was investigated under the conditions predicted against the responses obtained for enhanced L-dopa production. A slightly differential correlation was observed between the observed and predicted values. The optimal levels of the significant process parameters for improved L-dopa production in shaking culture were time course (48 h), initial pH (5.5), use of grinded mycelia, optimal glucose level (6%, w/v), peptone (1.5%, w/v), yeast extract (1%, w/v), ammonium chloride (0.2%, w/v) and potassium dihydrogen phosphate (0.3%, w/v). The optimal tyrosinase activity was recorded to be 64.55 U/mg. The statistical analyses of the responses for L-dopa production were also performed and are represented in Table 3. The correlation (0.012E+0025), A, B, C2 and D for E values depicts that the model was highly significant (p ≤ 0.05). Correspondingly, the lower probability values also indicated that the model terms were significant. The analysis of linear, quadratic and interaction coefficients were performed on the fermentative results which highlighted that L-dopa production was a function of the independent parameters [20,33]. The addition of organic and inorganic nitrogen sources along with potassium source (degree of freedom 3) was found necessary for maintaining the spatial conformation of the enzyme tyrosinase, and thus has an important physiological role in the L-dopa activity and stability.

Table 2. Application of Plackett-Burman design at various process parameters (designated by different captions) for L-dopa production by A. niger GCBT-8

Table 3. Statistical analysis of 2-factorial experimental design at various significant process parameters for L-dopa production by A. niger GCBT-8

Conclusion

Tyrosinase is an intracellular enzyme so mould mycelia of a locally isolated A. niger GCBT-8 were used for the biochemical conversion of L-tyrosine to L-dopa in an ascorbate-acidulated reaction mixture. The maximal L-dopa (0.365 mg/ml) was found at L-tyrosine consumption of 0.403 mg/ml. The process parameters particularly nature of the carbon-limiting substrate, medium composition and nutritional supplements for L-dopa production were determined using Plackett-Burman design. The correlation (0.012E+0025), A, B, C2 and D for E values depicts that the model terms were highly significant (p ≤ 0.05). However, further work on the optimization of mycelial and L-tyrosine concentration is in progress prior to scale up studies.

Abbreviations

L-dopa: 3,4-dihydroxy L-phenylalanine; rpm: revolutions per minute; Qp: mg L-dopa produced/ml/min; Yp/s: mg L-dopa produced/mg L-tyrosine consumed); qp: mg L-dopa produced/mg cells used/min; Qs: mg L-tyrosine consumed/ml/min); qs: mg L-tyrosine consumed/mg cells used/min; HS: highly significant; S: significant; LSD: significant difference; <p> significance level in terms of probability.

Competing interests

The authors declare that they have no competing interests.

Authors' contributions

SA conceived of the study and performed the experimental work. HI helped in the critical review and provided necessary facilities. The authors read and agreed to the final manuscript.

Acknowledgements

This work was completed by the collaborative support of Department of Botany and Institute of Industrial Biotechnology, GC University Lahore, Pakistan. We are extremely grateful to the honorable Vice Chancellor for his tremendous contributions to promote research culture in the University.

References

  1. Haneda K, Watanabe S, Takeda P: Production of 3,4-dihydroxy-L-phenylalanine from L-tyrosine by Microorganism.

    J Ferment Technol 1973, 51:398-406. OpenURL

  2. Rosazza KC, Paul GM, Wolf S: The microbial synthesis of L-Dopa.

    Biotechnol Lett 1995, 16:210-215. OpenURL

  3. Kumagai CB, Evan KL, Paul CC: Direct synthesis of levodopa from L-tyrosine.

    Biochemical J 1969, 108:507-511. OpenURL

  4. Koyanagi T, Katayama T, Suzuki H, Nakazawa H, Kozeki KY, Kumagai H: Effective production of L-Dopa with Erwinia herbicola cells carrying a mutant transcriptional regulator TyRr.

    J Biotechnol 2005, 115:303-306. PubMed Abstract | Publisher Full Text OpenURL

  5. Ali S, Haq I: Technique for improved production of 3,4 dihydroxy phenyl L-alanine by Aspergillus oryzae.

    Pak J Bot 2007, 39:623-627. OpenURL

  6. Daxenbichler ME, VanEtten CH, Earle FR, Tallent WH: L-Dopa recovery from Mucuna seed.

    J Agr Food Chem 1972, 20:1046-1048. Publisher Full Text OpenURL

  7. Haq I, Ali S: Mutation of Aspergillus oryzae for improved production of 3,4-dihydroxy phenyl L-alanine (L-DOPA) from L-tyrosine.

    Braz J Microbiol 2006, 37:78-86. Publisher Full Text OpenURL

  8. Rose JR, Rodriquez-Lopaz JN, Conovas GF: Effect of L-ascorbic acid on the monophenolase activity of tyrosinase.

    Biochemical J 1993, 295:309-312. OpenURL

  9. Park H, Lee J, Kim H: Production of L-dopa (3,4-dihydroxy L-phenylalanine) from benzene using a hybrid pathway.

    Biotechnol Bioengin 1998, 58:339-343. Publisher Full Text OpenURL

  10. Ali S, Haq I, Qadeer MA, Rajoka MI: Double mutant of Aspergillus oryzae for improved production of 3,4-dihydroxy L-phenylalanine (L-dopa) from L-tyrosine.

    Biotechnol Appl Biochem 2005, 42:143-149. PubMed Abstract | Publisher Full Text OpenURL

  11. Olsen W: Characterization of enzymes using catecholamine.

    Int Sugar J 1981, 83:102-105. OpenURL

  12. Raju BGS, Rao GH, Ayyanna C: Bioconversion of L-tyrosine to L-Dopa using Aspergillus oryzae. Visakha Ind. CBS Publishers, New Delhi, India; 1993.

  13. Tsuchida T, Nishimoto Y, Kotani T, Lizumi K: Method for increasing amino acids in Erwinia herbicola.

    1994.

    US Patent 3791924

  14. Ali S, Haq I, Qadeer MA: New trends in the production of 3,4-dihydroxy L-phenylalanine (L-dopa) from L-tyrosine.

    Pak J Biotechnol 2009, 7:214-219. OpenURL

  15. Haq I, Ali S, Qadeer MA: Biosynthesis of L-Dopa by Aspergillus oryzae.

    Bioresourc Technol 2002, 85:25-29. Publisher Full Text OpenURL

  16. Arnow LE: Colorimetric determination of the components of 3,4-dihydroxy L-phenylalanine-tyrosine mixture.

    J Biochem 1973, 118:531. OpenURL

  17. Kandaswami C, Vaidyanathan CS: Enzymatic assay of tyrosinase catechol oxidase activity.

    J Biol Chem 1973, 248:4035. PubMed Abstract | Publisher Full Text OpenURL

  18. Pirt SJ: Principles of Cell and Microbe Cultivation. Blackwell Scientific Corporation, London, UK; 1975.

  19. Snedecor GW, Cochran WG: Statistical Methods. 7th edition. Iowa State University Publishers, Iowa, USA; 1980.

  20. Ahuja SK, Ferreira GM, Morreira AR: Application of Plackett-Burman design and response surface methodology to achieve exponential growth of aggregated shipworm bacterium.

    Biotechnol Bioengin 2004, 85:666-675. Publisher Full Text OpenURL

  21. Krishnaveni R, Vandana-Rathod M, Thakur S, Neelgund YF: Transformation of L-tyrosine to L-dopa by a novel fungus, Acremonium rutilum, under submerged fermentation.

    Current Microbiol 2009, 58:122-128. PubMed Abstract | Publisher Full Text OpenURL

  22. Charles JS, Foss P, Rosazza J, Lemberger M: Microbiological synthesis of 3,4-dihydroxyphenylalanine.

    J Am Chem Soc 1969, 91:22. OpenURL

  23. Hee SP, Lee JY, Kim HS: Production of L-Dopa from benzene using a hybrid pathway.

    Biotechnol Bioengin 1998, 58:339-343. Publisher Full Text OpenURL

  24. Ho PY, Chiou MS, Chao AC: Production of L-Dopa by tyrosinase immobilized on modified polystyrene.

    Appl Biochem Biotechnol 2003, 111:139-152. PubMed Abstract | Publisher Full Text OpenURL

  25. Mason HS: Mechanism of the oxidation of 3,4-dihydroxy L-phenylalanine by tyrosinase.

    J Biol Chem 1984, 172:83. OpenURL

  26. Evan WC, Raper HS: A comparative study of the 3,4-dihydroxy L-phenylalanine from L-tyrosine by tyrosinase from various sources.

    J Biochem 1977, 31:2155-2170. OpenURL

  27. Sarin AN, Bedi KL, Chopraw CL, Attel CK: Bioconversion of L-tyrosine to L-Dopa.

    Ind J Microbiol 1980, 20:122-124. OpenURL

  28. Lee SG, Rao HS, Hong SP, Kim EH, Sung MH: Production of L-Dopa by thermostable tyrosine phenol-lyase of a thermophilic Symbiobacterium spp. overexpressed in recombinant Escherichia coli.

    Microbial Biotechnol 1996, 6:98-102. OpenURL

  29. Scribhers E, Tang T, Bradley SG: Production of a sporulation pigment by Streptomyces venezeuilae.

    Appl Microbiol 1973, 25:873-879. PubMed Abstract | PubMed Central Full Text OpenURL

  30. Dastager SG, Li WJ, Dayanand A, Tang SK, Tain XP, Zhi YZ, Xu LH, Jiang CL: Separation, identification and analysis of melanin production in Streptomyces.

    Af J Biotechnol 2006, 5:1131-1134. OpenURL

  31. Huang SY, Hung CH, Chopra SN: Innovative strategies for operating of mist trickling reactors for enhanced hairy root proliferation and secondary metabolite productivity.

    Enz Microbial Technol 1998, 35:22-32. Publisher Full Text OpenURL

  32. Kuo WN, Kocis JM, Guruvadoo LK: Modifications of tyrosinase and catechol amines by peroxy nitrite and nitrate.

    Fron Biosci 2008, 8:139-142. Publisher Full Text OpenURL

  33. Burkert JFM, Kalil SJ, Filho FM, Rodrigues MI: Parameters optimization for enzymatic assays using experimental design.

    Braz J Chem Engin 2006, 23:163-170. OpenURL