Email updates

Keep up to date with the latest news and content from BMC Systems Biology and BioMed Central.

Open Access Research article

Mapping global effects of the anti-sigma factor MucA in Pseudomonas fluorescens SBW25 through genome-scale metabolic modeling

Sven EF Borgos12, Sergio Bordel3, Håvard Sletta2, Helga Ertesvåg1, Øyvind Jakobsen2, Per Bruheim1, Trond E Ellingsen2, Jens Nielsen3 and Svein Valla1*

Author Affiliations

1 Department of Biotechnology, Norwegian University of Science and Technology, Trondheim, N 7491, Norway

2 Department of Biotechnology, SINTEF Materials and Chemistry, Sem Sælands v. 2A, Trondheim, N 7465, Norway

3 Department of Chemical and Biological Engineering, Chalmers University of Technology, Kemivägen 10, Gothenburg, SE 412 96, Sweden

For all author emails, please log on.

BMC Systems Biology 2013, 7:19  doi:10.1186/1752-0509-7-19

The electronic version of this article is the complete one and can be found online at: http://www.biomedcentral.com/1752-0509/7/19


Received:5 October 2012
Accepted:6 February 2013
Published:11 March 2013

© 2013 Borgos et al.; licensee BioMed Central Ltd.

This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract

Background

Alginate is an industrially important polysaccharide, currently produced commercially by harvesting of marine brown sea-weeds. The polymer is also synthesized as an exo-polysaccharide by bacteria belonging to the genera Pseudomonas and Azotobacter, and these organisms may represent an alternative alginate source in the future. The current work describes an attempt to rationally develop a biological system tuned for very high levels of alginate production, based on a fundamental understanding of the system through metabolic modeling supported by transcriptomics studies and carefully controlled fermentations.

Results

Alginate biosynthesis in Pseudomonas fluorescens was studied in a genomics perspective, using an alginate over-producing strain carrying a mutation in the anti-sigma factor gene mucA. Cells were cultivated in chemostats under nitrogen limitation on fructose or glycerol as carbon sources, and cell mass, growth rate, sugar uptake, alginate and CO2 production were monitored. In addition a genome scale metabolic model was constructed and samples were collected for transcriptome analyses. The analyses show that polymer production operates in a close to optimal way with respect to stoichiometric utilization of the carbon source and that the cells increase the uptake of carbon source to compensate for the additional needs following from alginate synthesis. The transcriptome studies show that in the presence of the mucA mutation, the alg operon is upregulated together with genes involved in energy generation, genes on both sides of the succinate node of the TCA cycle and genes encoding ribosomal and other translation-related proteins. Strains expressing a functional MucA protein (no alginate production) synthesize cellular biomass in an inefficient way, apparently due to a cycle that involves oxidation of NADPH without ATP production. The results of this study indicate that the most efficient way of using a mucA mutant as a cell factory for alginate production would be to use non-growing conditions and nitrogen deprivation.

Conclusions

The insights gained in this study should be very useful for a future efficient production of microbial alginates.

Keywords:
Pseudomonas; Polysaccharide; Alginate; Genome-scale metabolic modeling

Background

Pseudomonas is a genus of Gram-negative bacteria with features that have made them interesting to a wide community of researchers for a long time. Pseudomonas spp. range from important human pathogens (P. aeruginosa), via biocontrol agents and plant commensals useful in agriculture (P. fluorescens) to one of the most widely used “cell factories” for production of high-value-added products in industrial biotechnology (P. putida), and the genus is characterized by a great metabolic versatility.

Several species of Pseudomonas are also notable and well-studied in their capability to form biofilms [1], aggregates of cells that adhere to each other and to surfaces, embedded in an extracellular polymeric matrix. Formation of such biofilms can have serious clinical consequences, as seen in infections by the opportunistic human pathogen P. aeruginosa. Patients that are immunocompromised, including the general aging population, are susceptible to this pathogen both topically and systemically, and among cystic fibrosis patients, lung infections by P. aeruginosa are prevalent and have a major impact on morbidity and mortality [2,3].

One striking feature that is present in the majority of P. aeruginosa infections of the CF lung, is the so-called mucoid conversion of the pathogen, yielding a phenotype that produces large amounts of the exopolysaccharide alginate. This phenotype correlates with the ability of P. aeruginosa to persist in the lungs of CF patients [4] and is a general marker of poor survival for these patients [5]. The mucoid conversion typically takes place through inactivating mutations arising in the regulatory gene mucA[6], or proteolytic degradation of the encoded MucA protein [7]. MucA acts as an anti-sigma factor, binding and sequestering the alternative sigma factor σ22, encoded by the algU gene, that is essential for alginate production [8]. σ22 sigma factors are members of the ECF (extra cytoplasmic function) family of transcription factors that are known to respond to membrane stresses, and a recent microarray analysis [9] found that AlgU is a global stress response sigma factor, inducing several systems apart from alginate biosynthesis. This study also identified gene subsets encoding virulence factors specifically induced on conversion to mucoidy, including HCN biosynthesis. The metabolic features controlled by the AlgU-MucA system are not well studied, but a very recent metabolic footprinting study concluded that MucA modulates osmotic stress tolerance [10].

Alginate is a linear copolymer of mannuronic acid and its C-5 epimer guluronic acid, and bacterial alginate is only known to be produced by two genera, Pseudomonas and Azotobacter. An important industrial polymer, alginate is produced in bulk from seaweeds, but bacterial alginates have attracted significant interest over the last years due to the presence of alginate modifying enzymes, i.e. epimerases [11], in the producing organisms. These enzymes, taken together with the possibility to produce very homogeneous alginate from liquid bacterial cultivations, allow precise manipulation of the relative content and sequence of mannuronic and guluronic acid residues in the alginate, which influences the physico-chemical and immunological properties of the purified polymer significantly [12]. The genes encoding the alginate biosynthetic machinery are highly similar in the producing species, and are in Pseudomonas spp. organized in a 12-gene operon (algD–8–44–K–E–G–X–L–I–J–F–A) under the algD promoter – the only exception being the algC gene, encoding a phosphomannomutase, that is localized outside of the operon and transcribed from its own promoter. The alginate biosynthetic pathway (for reviews, see e.g.[13,14]) originates from fructose-6-phosphate and proceeds via the activated monomer GDP-mannuronic acid, to concomitant polymerization and export to the extracellular space. During the polymerization/export, mannuronic acid residues can be epimerized to guluronic acid, and can be O-acetylated in the O-2 and/or the O-3 position. One molecule of GTP and two molecules of NAD+ are consumed per monomer unit incorporated (counting from fructose-6-phosphate), whereas the degree of acetyl group incorporation depends strongly on the producing species [15]. P. fluorescens SBW25 is an organism well suited for industrial production of alginate as compared to either P. aeruginosa or A. vinelandii, because of both its non-pathogenicity and the relative simplicity of cultivation on an industrial scale.

Genome-scale metabolic reconstruction has become a well-established method for analysis of microbial metabolism, with numerous applications [16,17]. Although not directed towards dynamic modeling by nature, the steady-state assumption that underlies a stoichiometric metabolic reconstruction is well approximated in continuous liquid culture. Based on the annotated genome, the full spectrum of available metabolic pathways in the organism is reconstructed, and coupled with isotope labeling experiments, the actual flux distribution between these pathways can be assessed [18]. Alternatively, global data sets, most commonly transcriptomics data, can be used to identify highly regulated parts of the metabolic network [19], even if the metabolic reconstruction does not contain representations of regulatory mechanisms per se. This, in combination with computer simulations of gene knock-outs or knock-ins in the stoichiometric model, can identify attractive targets for metabolic engineering in the organism [20].

In this study, we have investigated the plant commensal P. fluorescens SBW25 by genome-scale modeling complemented by chemostat cultivations and microarray analysis of gene expression. The recently published genome sequence of SBW25 [21] (accession number [EMBL:AM181176]) shows that it contains all genes necessary for alginate biosynthesis, and from previous work, we have demonstrated the potential for high levels of alginate production in P. fluorescens[22]. Through genome-scale metabolic modeling, we aim to identify genetic and metabolic features that are crucial for alginate biosynthesis. The close coupling of alginate biosynthesis to central carbon metabolism necessitates a systems biology approach, and the results gained from the investigation of this non-pathogenic alginate producer could help to identify both novel antimicrobial targets for human medicine and key pathways features for optimized production of an industrially important biopolymer. Furthermore, we could by using the genome-scale model for performing integrative analysis identify the global role of the anti-sigma factor MucA on metabolism. The P. fluorescens metabolic reconstruction complements existing models of P. aeruginosa[23] and P. putida[24,25] and allowed us to perform a comparative metabolic analyses of these three important pseudomonads.

Results and discussion

Strain constructions

P. fluorescens wild-type strains have not been found to produce alginate under laboratory conditions, whereas it is known that mucA deficient strains of P. aeruginosa do(see e.g.[26]). An SBW25 mucA strain was constructed by introducing a point mutation leading to a truncated version of MucA in which the 37 C-terminal amino acids are absent. The algC gene is the only one located outside the alg operon that encodes an alginate biosynthetic enzyme. Whereas expression of the alg operon genes is known to be regulated by MucA, this is not the case for algC in P. fluorescens (unpublished results).

As the absence of a functional MucA protein in the cell is expected to have pleiotropic effects beyond alginate biosynthesis [9], it was necessary to construct control strains in order to discern between effects caused by alginate production, by over-producing the alginate biosynthetic enzymes, and by the more general pleiotropic effects of a defective anti-sigma factor MucA. In addition to the wild-type and the alginate-producing mucA strain, three control strains were constructed as described in Additional file 1. Relevant phenotypical features of the strains used in this study are summarized in Table 1. Firstly, the in-frame deletion inactivation of algC, i.e. a ΔalgC strain, encoding wild-type MucA would allow us to observe potential roles of AlgC outside the alginate biosynthetic pathway, including consequences of potential effects on LPS [27] and rhamnolipid [28] biosynthesis. Secondly, a mucA ΔalgC strain would not produce alginate, but would show pleiotropic effects following from mucA inactivation and, importantly, the cellular effect of overproducing the remaining alginate biosynthetic proteins. Finally, strain mucA TTalgD was constructed that does not produce alginate, as a transcription terminator (TT) is inserted between PalgD and the translation start of algD. This strain should still exhibit the pleiotropic effects of mucA inactivation, although with minimal alginate-related effects as neither alginate nor the alginate biosynthetic proteins (except AlgC) should be produced. It needs mentioning, however, that very recently, Paletta and Ohman [29] found two putative promoters internal to the alg operon in P. aeruginosa, upstream of the alginate epimerse gene algG and the alginate acetylation gene algI, respectively. This could indicate the possibility of differential regulation within the operon to alter polymer structure under varying conditions.

Additional file 1. An overview of the strains and plasmids used in this study.

Format: DOCX Size: 27KB Download fileOpen Data

Table 1. Overview of alginate-related phenotypes in the strains used in this study

Chemostat cultivations

Chemostat cultivation, allowing precise control of the cellular specific growth rate μ, ensures maximal homogeneity of the sampled cellular population both in the spatial and temporal dimensions (steady-state conditions) provided genetic stability.

A preliminary screening of carbon sources in P. fluorescens fermentations indicated that fructose and glycerol supported a significantly higher alginate yield per mmolC than did either glucose, sucrose, galactose, lactose or lactate. As both the uptake mechanism and point of entry into metabolism is different for fructose and glycerol, both carbon sources were selected for cultivations. Fructose is imported by the fructose-specific PTS FruAB-system [30], yielding fructose-1-phosphate, whereas glycerol is taken up by GlpF-facilitated diffusion and concomitant phosphorylation to glycerol-3-phosphate upon cytoplasmic entry [31]. For biosynthesis of alginate, fructose-1,6-bisphosphate is then the common precursor from both fructose and glycerol, from fructose by direct phosphorylation of fructose-1-phosphate, and from glycerol-3-phosphate via triose phosphates. Fructose-6-phosphate is then generated from fructose-1,6-bisphosphate by fructose bisphosphatase, and is the immediate substrate for the alginate biosynthetic enzymes by first converting fructose-6-phosphate to mannose-6-phosphate. Note that similarly to other pseudomonads, SBW25 does not contain a phosphofructokinase, thus lacking the possibility to phosphorylate fructose-6-phosphate.

In addition to the SBW25 wild-type (WT) strain, two genetically engineered strains were grown on both carbon sources in order to elucidate the impact of alginate biosynthesis on cellular metabolism. As described above, the mucA strain has the full mucoid phenotype, whereas the mucA TTalgD strain has a second mutation that abolishes expression of the alg operon biosynthetic genes. In the fructose cultivations, the two additional control strains ΔalgC and mucA ΔalgC were included to better understand the effects of MucA outside alginate biosynthesis as discussed above.

Chemostat cultivations were performed as described in Materials and Methods, with fructose or glycerol as the sole carbon source (both 40 g/l), under nitrogen limitation of growth. Measured variables were biomass concentration, residual carbon source in the medium, alginate production and CO2 evolution (respiration). In a chemostat, specific growth rate is fixed and based on this, specific rates of carbon source uptake, carbon dioxide production and alginate production were calculated, and the data are summarized in Table 2. Carbon balance calculation, as listed in the rightmost column, shows that all carbon taken up can be accounted for to within 95% in all conditions tested.

Table 2. Physiological characteristics of the strains and conditions studied

Bacterial alginates are O-acetylated to varying degrees [15]. The degree of acetylation was determined by HPLC measurements of acetate released from the alginate by hydrolysis to be 0.19 and 0.32 on fructose and glycerol, respectively. No free acetate was detected in the culture growth media.

It is apparent from Table 2 that the mucA inactivation has a profound effect on respiration in P. fluorescens SWB25. Whereas the measured differences between the WT strain and the ΔalgC mutant on fructose are negligible, the mucA ΔalgC mutant, which also does not produce alginate, has a significantly lower respiration, and hence a lower fructose uptake. This is even more pronounced in the mucA TTalgD strain, which makes neither alginate nor the dedicated alginate biosynthetic proteins. In the mucA strain, respiration is still low, whereas the fructose uptake is strongly elevated to accommodate the carbon drain into alginate. On glycerol, the reduction in respiration going from the WT strain to the mucA mutant reflects the case on fructose, whereas the mucA TTalgD strain on glycerol has a level of respiration that is intermediate to those of the WT and mucA strains, as opposed to the fructose case. This is an early indication that metabolism of the two carbon sources is regulated differently in P. fluorescens SBW25.

Transcriptome analyses

Based on the annotated P. fluorescens SBW25 genome sequence, a custom expression microarray was constructed for transcriptome analysis. This array covers 6,519 genes, including 478 genes from the environmental plasmid pQBR103. The apparent discrepancy with the 6,009 chromosomal genes published by Silby et al.[21] is due to the inclusion of some putative pseudogenes in the microarray. Note that the pQBR103 plasmid included in the published genome sequence was shown to be acquired by the organism during a field release experiment [32], and is not present in the originally isolated SBW25 strain used in this study; it was included in the microarray design for versatility in potentially comparative studies.

RNA samples were isolated from triplicate, independent chemostat cultivations as described above. The complete transcriptome data set is available in Additional file 2, both as raw and quantile normalized data. Process variability in RNA isolation, preparation and analysis was investigated (data not shown), confirming that the majority of the observed variability between replicates does indeed represent biological differences between cultivations. Principal component analysis (PCA) was performed on the transcriptome data described here, and the results are shown in Figure 1. It confirms that there is good reproducibility within replicate sample sets. There is a clear PCA separation of the strains into three distinct groups, along the two first principal components. (Figure 1a,c). The mucA and mucA ΔalgC strains grown on fructose are separated from each other, and from the remaining three strains which cluster closely together. The mucA ΔalgC is phenotypically distinct in that it does not produce alginate, but the alginate biosynthesis genes are transcribed and translated. The anti-sigma factor MucA is effectively a global regulator through the MucA–AlgU system, and a strong effect on cellular processes can be expected. Interestingly, the mucA TTalgD strain, which does not make either alginate or most of the alginate biosynthetic enzymes, does not group with either the mucA or the mucA ΔalgC strains, but rather with the WT. This could indicate that even the expression of only the alginate biosynthetic enzymes with no concomitant alginate biosynthesis (as is the case in the mucA ΔalgC strain) imparts a significant physiological load on the cells. This is supported by the observation that when genes are clustered according to their expression pattern across all strains (data not shown), virtually all genes encoding ribosomal proteins show an expression profile similar to that of the alg operon (i.e. high relative expression in the mucA and mucA ΔalgC strains). It should also be noted that in the PCA plots, the mucA strain on glycerol is clustered with the mucA ΔalgC strain, rather than the mucA strain, on fructose (Figure 1a), although a separation between carbon sources can be observed along PC3 (Figure 1b). This somewhat counterintuitive clustering could be an indication that the mucA inactivation has different physiological effects depending on the carbon source utilized by the cells.

thumbnailFigure 1. PCA plots of microarray data from chemostat cultivations.Panel 1a): All strain–carbon source datapoints, PC1 (principal component 1, x axis, 85.1% explained variation) vs. PC2 (y axis, 9.3% explained variation). Panel 1b): All strain–carbon source datapoints, PC3 (x axis, 5.5% explained variation) vs. PC2 (y axis, 9.3% explained variation). Panel 1a and 1b will combine to show all three dimension in three first PCs. Panel 1c): All datapoints from fructose-grown cultivations, PC1 (90.1% explained variation) vs. PC2 (7.4% explained variation). Squares, carbon source fructose; triangles, carbon source glycerol. Strains: Grey, WT; yellow, ΔalgC; red, mucA; blue, mucA ΔalgC; green, mucA TTalgD. All datapoints are independent fermentations, i.e. all biological conditions are present in triplicate data points. Genes used to construct the PCA are selected by ANOVA with p-values < 0.005.

Additional file 2. The complete microarray data, both in raw and quantile normalized formats.

Format: XLSX Size: 3.1MB Download fileOpen Data

If only the subset of metabolic genes is considered and all mutant strains on fructose are compared against the WT, the indicative differences observed in the PCA plot are confirmed. Using 2-fold regulation and ANOVA p-value of < 0.005 as significance cut-off, no metabolic genes are changed in the ΔalgC mutant, whereas in the mucA TTalgD strain, only algC and the PFLU5987 gene are regulated above the significance cut-off, both up in the mutant strain. The latter gene encodes an acetylglutamate kinase ArgB (EC 2.7.2.9). However, this gene is localized immediately downstream of algC on the chromosome, and they are most likely co-transcribed.

In the mucA strain, and to some extent in the mucA ΔalgC strain, two functional sets of genes besides the alginate biosynthetic operon are recognized as significantly upregulated, in addition to the genes encoding ribosomal proteins and other translator proteins. The first category encompasses genes directly involved in energy generation, including the ATP synthase subunits, cytochrome C encoding genes and NADH dehydrogenase genes. This correlates very well with the recent findings by Lien et al.[33] on metabolome changes in P. fluorescens SBW25, where it is shown that the most significant metabolome changes are changes in the GXP pool related to alginate synthesis and changes in the AXP pool related to mucA inactivation. The second notable set of upregulated genes encode functions on both sides of the succinate node in the TCA cycle, i.e. the succinate dehydrogenase and succinyl-CoA synthetase complexes. In this context, it is noteworthy that succinate dehydrogenase is the only enzyme that catalyzes reactions in both the TCA cycle and the electron transport chain. Other metabolic genes upregulated above the 2-fold threshold in the mucA strain include the purine pathway genes purF, purN; carbonic anhydrase; isocitrate dehydrogenase; S-adenosylmethionine synthetase; PEP synthase and both isoenzymes of glucose-6-phosphate dehydrogenase.

The genes PFLU3193–PFLU3201 display a remarkable expression profile that is unique in the transcriptome data, where the mucA inactivation seems to have opposite effect depending on the carbon source. As these genes have the same direction on the chromosome and very short intergenic linkers, it seems probable that they are co-transcribed. The genes upstream and downstream, PFLU3192 and PFLU3202, do not share the same expression profile. Normalized gene expression profiles for the first gene in the putative operon is shown in Figure 2; the downstream genes show very similar expression profiles (data not shown), supporting the assignment of these genes to an operon structure. The expression level is upregulated approximately twofold on fructose compared to the wild-type, in the alginate producing mucA strain, whereas this ratio is inverted in the glycerol-grown cultures. Absolute expression values in the two cases also vary approx. twofold between carbon source conditions for the alginate producing strain, indicating that expression of these genes is regulated in a multifactorial way. All of the genes in this putative operon are indicated by BLAST sequence similarity to encode metabolic enzymes; PFLU3193 shows high similarity to 2-ketoacid dehydrogenase subunits, more specifically to pyruvate dehydrogenase subunit E1. For the remaining genes in the cluster, the exact reaction catalyzed is less clear, although there is a strong indication of an involvement in fatty acid biosynthesis or metabolism, as encoded by the presence of 3-ketoacyl-acyl carrier protein (ACP) synthases (PFLU3201 and PFLU3199), ACP (PFLU3200), acyl-CoA oxidase (PFLU3198) and a possible thioesterase (PFLU3197). Alternatively, these enzymatic activities could participate in biosynthesis of polyketides; other strains of P. fluorescens are known to produce such compounds, including mupirocin [34], 4-diacetylphloroglucinol [35] and pyoluterin [36]. In such a context, it is also interesting to note that for all the genes PFLU3196–PFLU3201, the BLAST hits with the highest similarity originate from members of the Streptomyces genus, known for their extensive polyketide biosynthetic capabilities.

thumbnailFigure 2. Differential gene expression profiles in carbon source regulated operon. Gene expression profiles (log2 normalized expression values) in all strain–carbon source combinations for gene PFLU3201, which is the first gene in the putative operon PFLU3201–PFLU3193. Dark grey, fructose as carbon source; light grey, glycerol as carbon source. Data points are averages of three independent cultivations; error bars equals one standard deviation.

Genome-scale metabolic modelling

Metabolic reconstruction at the genome level

Reconstruction of an organism's complete metabolic network comprises the assignment of well-defined biochemical reactions to gene products, and the integration of these reactions into a set that allows for simulation of cellular growth, i.e. the conversion of growth substrates into biomass and by-products (e.g. CO2), and potentially the production of secondary metabolites like biopolymers. The stoichiometry and completeness of the reaction network is then validated by comparison of the simulated results with wet-lab experiments. It is worth noting that most genome-scale reconstructions up to date make the simplifying assumption that growth occur under steady-state conditions, so that the simulation can be run as purely stoichiometric on an elemental basis without time-dependent changes. Also, the effect of regulation, which is critical to any organism's adaptation to its environment, is usually ignored in the steady-state assumption, although some work is beginning to appear that integrates data on regulation with the metabolic network structure [37].

The manual reconstruction of a metabolic network continues to be a labour-intensive process that is mainly based on incorporation of knowledge published previously on the organism in question. Since the first genome-scale reconstructions were completed, the use of software and databases for aid in this process has gathered significant and increasing attention. Although the essential data is mostly interconvertible between the different model formats, the choice of reconstruction software will have some influence on the exact model building strategy, format and workflow. An attempt to automate the reconstruction process for bacteria is the SEED database [38], which maps genes through a web interface to a pre-constructed metabolic network, generating a draft model in SBML format that can in principle be used directly for simulations. Another software package for model reconstruction is the Pathway Tools suite [39,40], which is built around the BioCyc database collection of metabolic pathways encompassing virtually all domains of life; currently, 1129 genomes and their respective databases are contained in BioCyc. The comprehensiveness and degree of manual database curation, as well as the fact that Pathway Tools is still in active development almost a decade after it was launched, contributed strongly to the decision of making it a central tool in this work.

A more recent development in the quest for (semi-)automation of the reconstruction process is the RAVEN Toolbox software suite [Agren et al., submitted] [41] that integrates both the reconstruction and subsequent flux simulations on the model. One significant advantage of the latter approach is the complete control that the user exerts on every sub-step of the model construction; the reconstructed network and the input parameters for simulation all reside in a spreadsheet format that constitutes a detailed, intuitive and easily accessible overview of all reactions, metabolites, genes and simulation parameters.

Here, a hybrid approach was pursued, combining the proven reconstruction power of the Pathway Tools software with the user accessibility and simulation power of the RAVEN Toolbox. Based on the annotated P. fluorescens SBW25 genome [21] we used Pathway Tools v12.0 to reconstruct a draft metabolic model, as described in Materials and Methods. As the model reconstructed in Pathway Tools was not formulated or formatted for simulation purposes, the model was restructured into RAVEN Toolbox format.

The final model contains 1194 metabolites participating in 1012 unique biochemical reactions, of which 126 are transport reactions. 1139 ORFs are associated to the reactions, and 367 of the proteins encoded participate in 112 protein complexes. The model is denoted iSB1139 by nomenclature convention [42], and the distribution of reactions in functional classes is shown in Figure 3.

thumbnailFigure 3. Reaction classes present in the iSB1139 metabolic network. Classification and distribution of all reactions in the iSB1139 genome-scale metabolic model of P. fluorescens SBW25 into functional groups of the overall metabolic network.

Comparison between Pseudomonas genome-scale models

Genome-scale metabolic reconstructions of bacteria are conceptually similar, the differences being mainly the selection and number of entities (genes, reactions, metabolites) included in each reconstruction. We performed a reaction-by-reaction manual comparison of the three Pseudomonas genome-scale models considered here, iJN746 (P. putida KT2440) [25], iMO1056 (P. aeruginosa PAO1) [23] and iSB1139 (P. fluorescens SBW25, this work). The complete comparison in tabular format can be found in Additional file 3. Reactions in the P. putida model describing diffusion from periplasm to extracellular space were excluded, as were so-called exchange reactions in both the P. putida and P. fluorescens models. Such exchange reactions are added to facilitate flux simulations, but do not represent cellular processes. The complement of shared and unique reactions between the three Pseudomonas models is visualized as a Venn diagram in Figure 4. All three models have a shared core inventory of 482 reactions. The alginate biosynthetic genes, of special interest here, are conserved in the P. aeruginosa and P. fluorescens models, but are not included in the P. putida model, although the genes are present in the organism.

thumbnailFigure 4. Metabolic reaction overlap and uniqueness in published Pseudomonas models. Venn diagram of reactions present in the iMO1056 (P. aeruginosa PAO1), iJN746 (P. putida KT2440) and iSB1139 (P. fluorescens SBW25) genome-scale metabolic models discussed here.

Additional file 3. A spreadsheet comparison and alignment of the reactions present in the published Pseudomonas genome-scale models iMO1056, iJN746 and iSB1139.

Format: XLSM Size: 461KB Download fileOpen Data

Among reactions unique to the iMO1056model of P. aeruginosa, two functional groups stand out in numbers; the first group is transport (46 reactions) with unique substrates or unique transport mechanisms on common substrates. The second group constitutes biosynthesis of virulence factors (44 reactions), including LPS/lipid A biosynthesis, quorum sensing biosynthetic pathways and phenazine biosynthesis, reflecting the pathogenic lifestyle of P. aeruginosa and its emphasis in the modeling process.

For the iJN746 P. putida model, degradation of aromatic compounds, including the beta-ketoadipate pathway, constitutes 56 reactions unique to this model, whereas the biosynthetic pathway for the industrially relevant polymer polyhydroxyalkanoate (PHA) contains 26 unique reactions. The existence of an alternative, 12-step lysine degradation pathway in P. putida, as described by Revelles et al.[43] is also noteworthy in the comparison of metabolic capabilities contained in the three models, as this pathway has been suggested [44] to replenish TCA cycle intermediates.

In the P. fluorescens model, unique reactions encompass a significant number concerning transport (33 reactions). Metabolism of alternate carbon compounds, either as complete pathways (e.g. metabolism of 4-hydroxyphenyl acetate) or as smaller sets of reactions, constitute a significant fraction of these unique reactions; some are introduced by the reconstruction software without being well connected to the metabolic network. They are, however, retained in the model so it can serve as a knowledge base for the organism and also for the future potential integration in the main metabolic network as improved annotation of metabolic genes becomes available. These detached reactions are not detrimental to the flux simulations as they are excluded from the working SBML model.

When assessing model completeness, 27 reactions are found to be part of both the P. aeruginosa and P. putida model, but not included in the P. fluorescens model described here. All of these, however, represent reactions with dead-end metabolites, reactions with alternative cofactors, transport reactions or reactions already described (above) as absent from the P. fluorescens SBW25 model. Thus, no significant metabolic 'holes' exist solely in the P. fluorescens model. Comparison of manually constructed genome-scale models is challenging, in that the reconstruction process involves a significant number of non-standardized decisions, notably in the association of metabolic reaction substrates, products and cofactors to genes and gene products. Oberhardt et al. [45] have very recently developed an elaborate process for reconciliation of genome-scale metabolic models, and demonstrated its application on the previously published models of P. aeruginosa PAO1 and P. putida KT2440. Although the described process was based on a manual reconciliation of the two models, the authors suggest a workflow that should be amenable to a degree of automation and might provide a first step on the path towards full multi-model comparisons on a metabolic network level.

Estimation of biomass composition and energetic parameters in the iSB1139 model

Biomass composition in the iSB1139 model was chosen to be identical to that used for the P. putida iJN746 model [25], in turn based very closely on measured values for E. coli[46,47]. For the second P. putida KT2440 model iJP815 [24], simulations indicated that using the experimentally verified biomass composition for E. coli, in the absence of experimental data for P. putida, was a sound approximation. Furthermore, Roels [48] found very similar elemental composition and ash content for P. fluorescens and E. coli under unlimited growth. The growth associated ATP consumption that we have used is an average between the values for P. putida and P. aeruginosa (both closely based on the value from E. coli), which is equal to 43 mmol of ATP per gram of biomass produced.

The annotated genome of P. fluorescens SBW25 indicated the presence in the electron transport chain of at least three terminal oxidases, cytochrome c oxidase, bd (ubiquinol) oxidase and bo (ubiquinol) oxidase, with different ATP-generating efficiencies. Such complementary systems are thought to be optimized for cellular energy generation under different dissolved oxygen tension in the cytoplasm [49,50].

While cytochrome c oxidase translocates 6 protons for each pair of electrons transferred to oxygen, bd and bo translocate only 2 protons. The overall theoretical P/O ratio (in absence of proton leakages across the membrane) can therefore vary between 2.5 and 1.5 depending on which terminal oxidase is active.

Theoretical and experimental biomass yields

The strains not producing alginate show different biomass yields on fructose (see Table 1). The wild type strain and the ΔalgC mutant have biomass yields of 0.14 g-DW/g-fructose, while the double mutants mucA ΔalgC and mucA TTalgD show yields of 0.23 and 0.24 g-DW/g-fructose, respectively. As calculated from the model, the optimal biomass yields in fructose using P/O ratios of 2.5 and 1.5, respectively, are 0.72 and 0.58 g-DW/g-fructose. A typical bacterial non-growth associated ATP consumption of 1.5 mmol-ATP per g-DW per hour [51] would explain only a further drop of 0.06 g-DW/g-fructose. This means that the experimental biomass yield is far from optimal and the cells are using inefficient biomass synthesis pathways or are dissipating energy in futile cycles. In the next section it will be shown that the difference in biomass yield between the wild type strain and the ΔalgC mutant with respect to the mucA ΔalgC and mucA TTalgD mutants can be explained by the activity of a cycle oxidizing NADPH without ATP production, which is consistent with a suboptimal metabolism in terms of energy utilization. This lack of optimality could be due to the difference in growth conditions between the chemostat situation (40 g/l of fructose or glycerol) and the native soil habitat of P. fluorescens, e.g. that the chemostat condition is one of relative carbon excess for which the metabolic network is not evolved optimally.

The same lack of optimality in the biomass yield can be observed when the cells grow using glycerol as a carbon source. The wild type and the mucA TTalgD strains show biomass yields of 0.16 and 0.20 g-DW/g-glycerol, while the optimal yields for P/O ratios of 2.5 and 1.5 respectively are 0.81 and 0.65 g-DW/g-glycerol.

Theoretical and experimental alginate yields

In order to calculate the actual efficiency of alginate biosynthesis of the alginate producing mucA strain we have subtracted from the carbon source consumed the amount of carbon that is dedicated to biomass production in the non-alginate-producing strain with the highest biomass yield, i.e. the maximum amount of carbon P. fluorescens SBW25 can channel into biomass under any of the conditions tested here. Alginate yields calculated on the remaining carbon available will then be relative to carbon used for alginate biosynthesis. The resulting efficiencies of alginate biosynthesis are 0.99 mmol-alginate/mmol-fructose and 0.5 mmol-alginate/mmol-glycerol. The theoretical yields on fructose using P/O ratios of 2.5 and 1.5 respectively are 0.93 and 0.85 mmol-alginate/mmol-fructose, which means that under the above approximation of an upper threshold of biomass yield, the alginate biosynthesis is operating close to its optimal stoichiometric yield. The alginate biosynthesis from glycerol does not require the oxidative phosphorylation and has a theoretical yield of 0.45 mmol-alginate/mmol-glycerol, which is independent of the P/O ratio chosen, this is due to the fact that, when glycerol is supplied as the carbon source, the metabolic network is flexible enough to compensate the difference in respiratory ATP yield by using the reaction catalyzed by pyruvate kinase as an alternative ATP source. The results seem to indicate that the cell is able to transform both carbon sources into alginate in a close to optimal way even if their biomass production is far from optimal. Indeed, the fraction of imported carbon that goes into alginate is very high; 71% and 68% on fructose and glycerol, respectively. All the above would indicate that in order to use the mucA strain as an optimal alginate-producing cell factory it could be enough to use it in non-growing conditions such as for example under nitrogen deprivation.

Random sampling

The functional association of the measured transcriptome data to actual metabolic fluxes is challenging, as it has been shown that there is no clear correlation between gene expression and protein concentration [52] or metabolic fluxes [53,54]. Recently, we developed a ‘convex basis random sampling’ method [55], which allows for a genome-scale statistical comparison of experimental gene expression changes and estimated metabolic fluxes. The advantage of this method is that it uses the observed changes (between two conditions) in a small set of experimentally measured fluxes such as respiration, carbon source uptake rate, secondary metabolite production etc. to infer the probabilities of flux change in each of the fluxes in the genome-scale metabolic network. This method facilitates the classification of enzymes as either transcriptionally regulated (i.e. showing significant correlation between flux change and gene expression change), metabolically regulated if change in the corresponding reaction is likely to be driven only by metabolite concentrations or post-transcriptionally regulated (i.e. where a significant expression change does not correlate with the estimated flux change). Each reaction in the network is assigned a score between 0 and 1, which indicates the likelihood for the reaction to be transcriptionally regulated. The reactions can be sorted by their corresponding scores in order to identify which transcriptional changes have a greater impact on the observed changes in the metabolic phenotype.

Here this method was applied to the genome-scale reconstruction of P. fluorescens SBW25. The experimental conditions for comparison in this case were the strain–carbon source combinations, whereas the measured variables were the microarray data sets and observed exchange fluxes in the chemostat cultivations, i.e. carbon source consumption and production of CO2 (respiration), alginate (including acetylation), and cell biomass. Note that specific growth rate was fixed at 0.04 hr-1 for all cultivations. Pairwise comparisons were done of the wild-type strain vs. all mutants on each carbon source.

Wild type versus mucA strain on fructose

In the alginate-producing mucA strain growing on fructose, unsurprisingly, the reactions involved in the alginate biosynthetic pathway, encoded by algD, algG, algX, algI, algJ, algF, algA and algC, appeared to be transcriptionally up-regulated with high evidence scores. The reaction PEP synthase (generating PEP for the fructose PTS transport system), which is associated in the model with the gene PFLU4620, shows a strong transcriptional up-regulation (with the 8th top ranking evidence score). This reaction is coupled to fructose transport and phosphorylation, which is consistent with the much higher specific fructose uptake rate in mucA compared with the wild type. The gene association that appears in the model is uncertain and the gene PFLU4620 is annotated as a putative PEP synthase. The fact that the flux in the reaction PEP synthase appears to be well correlated with the change in the transcription level of PFLU4620 indicates the gene association.

Interestingly, a highly significant transcriptional down-regulation of ribose-5-phosphate isomerase A (RpiA) is also found (with the 4th ranking evidence score). This enzyme is central in the pentose phosphate pathway. A down regulation of this pathway would mean that the cells produce less NADPH and more NADH.

The amount of energy required for alginate biosynthesis is significant; per mole of extracellular fructose incorporated in (extracellular) alginate, three moles of high-energy phosphate esters (PEP, ATP and GTP) are hydrolyzed, and two moles of NAD+ are reduced to NADH. From the random sampling analysis, pyruvate dehydrogenase cytochrome (PoxB), ubiquinol-cytochrome C reductase and cytochrome C oxidase appear as transcriptionally up-regulated reactions (6th, 9th and 10th evidence scores). The F0F1 ATP synthase appears ranked in the 15th position by evidence score. These alterations would support an increased ATP production rate in order to supply the necessary energy for alginate biosynthesis. As shown by Lien et al.[33], the most significant changes in the metabolome of SBW25 are alterations in the GXP and AXP pools upon biosynthesis of alginate and mucA inactivation, respectively. This is in good correlation with the results from the random sampling analysis.

Wild type versus ΔalgC mutant in fructose

Comparison of the ΔalgC mutant with the wild-type yielded only very small phenotypical changes and it was therefore not possible to detect any significantly perturbed fluxes using the random sampling algorithm.

Wild type versus the double mutants mucA ΔalgC and mucA TTalgD in fructose

For the double mutants mucA ΔalgC and mucA TTalgD, an interesting pattern occurs; the three highest ranked reactions identified as showing transcriptional regulation of their fluxes in the mucA ΔalgC strain (all down-regulated) form an NADPH oxidizing cycle together with the 9th ranked reaction (also down-regulated), with the overall net stoichiometry NADPH + H+ + ½ O2 → H2O + NADP+. The reactions underlying this cycle are:

(1) Aspartate aminotransferase (AatB; PFLU3176): L-glutamate + oxaloacetate → L-aspartate + alpha-ketoglutarate

(2) Catalase (KatB; PFLU5339): H2O2 → H2O + ½ O2

(3) NADP-specific glutamate dehydrogenase (GdhA; PFLU5326) : NADPH + alpha-ketoglutarate + NH4+ → L-glutamate + NADP+ + H2O

(4) L-aspartate oxidase (NadB; PFLU1465): L-aspartate + O2 + H3O+ → NH4+ + H2O2 + oxaloacetate

Strikingly, down-regulation of three of the above four reactions, specifically (2), (3) and (4) also rank within the top four in the mucA TTalgD strain, giving a strong indication that the same metabolic mechanism is functioning in this strain too.

Cyclic operation of pathways in central metabolism is widespread in bacteria [56], although such pathways rarely imply a direct dissipation of energy or cellular reductive potential, as suggested for the cycle (1)–(4). There are, however, examples both in bacteria [57,58] and yeast [59] where overproduction of NADPH, primarily from increased flux through the pentose phosphate pathway, causes a metabolic imbalance that must be corrected by reoxidation of NADPH without concomitant anabolism. Soluble transhydrogenases, like UdhA in E. coli[60], are considered important for NAPDH balancing in some species through the equilibrium NADPH + NAD+ ↔ NADP+ + NADH. However, as udhA analogs are only found in Enterobacteria, other mechanisms for NADPH reoxidation must exist. Fuhrer and Sauer [61] investigated growth and NADPH balancing in eight bacterial species, including P. fluorescens strain 52–1C, on glucose. They found that for six of these species, NADPH biosynthesis exceeded anabolic demands, and four of these six species relied on other redox-balancing systems than transhydrogenase reactions. Such systems were suggested to include dual cofactor specificities of catabolic enzymes or isoenzymes with distinctive cofactor specificities, as well as the possible existence of redox cycles and NADH kinases. In the P. fluorescens strain, NADPH biosynthesis seemed balanced under glucose growth, and the absence of soluble transhydrogenase activity was experimentally verified. Interestingly, Chavarría et al.[62] very recently demonstrated regulation of the pyruvate shunt (malate – pyruvate – oxaloacetate) in P. putida KT2440 by the PtsN paralog of the FruB fructose-specific PTS protein. When PtsN was inactivated, either by gene knock-out or by mutagenesis of the phosphorylation site, the flux through the pyruvate shunt was increased when either glucose or fructose was used as carbon source. Moreover, flux through the shunt was 2.4-fold higher on fructose (a PTS substrate) than on glucose (a non-PTS substrate). This is of relevance for the results reported here since the pyruvate shunt constitutes a seemingly futile bypass of one reaction in the TCA cycle, as ATP is hydrolyzed in the shunt. All the relevant genes described in the P. putida case (ptsP, ptsO, ptsN) are present (and virtually identical at the amino acid level) in P. fluorescens SBW25, strongly suggesting that similar mechanisms will be at play in the latter strain and thereby implying the conditional use of futile reactions in central metabolism as regulatory mechanisms.

For both the mucA ΔalgC and mucA TTalgD strains, the rpiA encoded ribose-5-phopshate isomerase A (PFLU5824) appears transcriptionally down-regulated compared to the wild type, with evidence scores ranking 4th and 10th in the two former strains, respectively. As suggested for the mucA strain, this could represent a reduced activity of the pentose phosphate pathway. For the wild-type and the ΔalgC strains, the cycle (1)–(4) could re-oxidise surplus NADPH generated by the higher flux through the pentose phosphate pathway, effectively generating a cycle dissipating reductive potential. Phenotypically, this would then translate into lower biomass yield, observable as higher relative respiration for the wild-type and the ΔalgC strains (see Table 2).

Wild type versus mucA TTalgD in glycerol

When glycerol is used as a carbon source, the random sampling algorithm could not identify any significant transcriptionally regulated fluxes in the alginate non-producing mucA TTalgD mutant relative to the wild type.

It is noteworthy that the reactions constituting the NADPH consuming cycle suggested above for two of the fructose-grown strains do not come out as significantly transcriptionally regulated in the wild type–mucA TTalgD comparison on glycerol. The genes aatB and katB showed a down-regulation in the mucA TTalgD with respect to the wild type that is as strong during growth on glycerol as on fructose; however the mentioned down-regulation does not seem to have any impact in the metabolic fluxes when glycerol is the carbon source, as the mentioned cycle is only modeled as active when the cells grow on fructose. This is in agreement with observed differences in respiration; if ratios of respiration per dry weight is calculated (from the values in Table 2) for the wild type relative to the mucA TTalgD mutant, this ratio is significantly higher when fructose is used as a carbon source (wild type = 7.5 mmolC/g-DW hr; mutant = 3.9 mmolC/g-DW hr; ratio = 1.92) than when glycerol is used (wild type = 6.4 mmolC/g-DW hr; mutant = 5.0 mmolC/g-DW hr; ratio = 1.28). Both in relative and absolute terms, the change in respiration as a function of the mucA inactivation is clearly more profound on fructose than on glycerol again supporting the hypothesis of an NADPH oxidizing cycle in operation when the wild type cells are growing on fructose.

Wild type versus mucA in glycerol

When the wild type and the mucA strains were grown with glycerol as the sole carbon source five proteins encoded by genes from the alginate biosynthetic operon are ranked 1st to 5th in the list of transcriptionally regulated enzymes, which is similar to the observations for this strain on fructose. Within the 6th to 10th ranking enzymes, two are directly involved in glycerol uptake and conversion (fructose bisphosphate aldolase Fba [PFLU5701] and the GlpF glycerol uptake facilitator protein [PFLU1143]), two contribute to energy generation by oxidative phosphorylation (the Ndh NADH dehydrogenase II [PFLU0783] and ATP synthase) and one (Ndk; nucleoside diphosphate kinase, PFLU5061) generates GTP from ATP for consumption in alginate biosynthesis. It thus seems that all the top ranking enzymes suggested to be transcriptionally regulated can be linked directly to the uptake and conversion of the carbon source into alginate when the organism is grown on glycerol. This is in contrast to the situation on fructose as described above, and it could indicate that although only a few biochemical steps are different between the pathways leading to alginate from fructose and glycerol, respectively, the organism seems to regulate the metabolism surrounding the alginate biosynthetic precursors and cofactors quite differently on the two carbon sources. This could be of relevance if metabolic engineering of the alginate biosynthesis were to be pursued.

Conclusions

We have described the reconstruction and application of a P. fluorescens SBW25 genome-scale metabolic model. Genetic engineering was used to construct selected strains with alterations in both the anti-sigma factor mucA and alginate-specific genes, and the physiological response was characterized by chemostat cultivations and transcriptome analysis. Integration of the metabolic model with the experimental data allowed us to obtain new insight about the metabolism of this producer of the commercially interesting biopolymer alginate. Firstly, we could show that the yields of alginate are close to the theoretical stoichiometric optimum, demonstrating the very high efficiency of the alginate biosynthetic machinery in this organism. We could also, however, see that the biomass production of P. fluorescens SBW25 is markedly suboptimal in the wild-type strain, and by the use of random sampling analysis in the transcriptome data set we could give strong indications that this suboptimality on fructose is related to a cycle in the central metabolism, effectively wasting cellular energy in the form of NADPH. This cycle does not seem to be active when the organism is grown on glycerol. The down-regulation of the suspected NADPH oxidizing cycle was observed in the mucA strains, adding to the putative regulon of this global regulator.

The model described in this work, validated by comprehensive continuous-culture experimental data and integrated with transcriptome analyses, nicely complements the existing P. aeruginosa and P. putida models. Alginate is a significant virulence factor in P. aeruginosa infections, and the emphasis on alginate biosynthesis in the (non-pathogenic) P. fluorescens system described here could support the clinical research on this important pathogen. Also, alginate is a valuable industrial product, and the optimization of alginate production in bacterial systems is of great commercial interest. As compared to the other major alginate-producing bacterial genus, Azotobacter, the relative simplicity that applies to both engineering and cultivating P. fluorescens – taken together with its highly efficient alginate biosynthesis as described here – should provide an argument for its applicability in an industrial context. The heterologous expression of Azotobacter alginate epimerases could then be used to produce high yields of alginates with tailored monomer sequences.

Methods

Strain construction

The plasmids and strains used in this study are described in Additional file 1. Plasmid isolations, enzymatic manipulations of DNA, agarose gel electrophoresis and other routine DNA manipulations were performed according to the methods of Sambrook and Russell [63]. The QIAquick Gel Extraction Kit and QIAquick PCR purification kit (Qiagen, Germany) were used for DNA-purifications from agarose gels and enzymatic reactions, respectively. PCR for cloning and allele identification was performed using the Expand High Fidelity PCR system (Roche Diagnostics, Switzerland). DNA was sequenced using the Big-Dye Terminator v1.1 Cycle kit (Applied Biosystems, CA). Transformations of E. coli were performed using the rubidium-chloride method (available at http://www.neb.com webcite). Matings and selection of double recombinants were performed as described earlier [22,64].

Cultivation and sampling

Triplicate chemostat experiments were performed in 3 liter fermenters (Applikon, Netherlands) with a 0.75 liter working volume and a feeding rate of 30 g/hr, corresponding to a dilution rate, D = 0.04. Inoculation of the chemostats was 3% from an overnight culture grown in LB medium (all growth media are described in Additional file 4), and the initial (batch phase) medium in the fermenter was Def4m. Temperature was controlled at 25°C, and pH was kept at 6.8 by addition of NaOH. Aeration was 0.5 liters per liter culture volume, and dissolved oxygen was controlled at 20% by adjusting stirrer speed. Feeding was started after 24 hrs, and was controlled on a weight basis. The chemostat feeding growth medium, Def4, was fully defined with either fructose or glycerol (both 40 g/l) as the carbon source. Exhaust CO2 was measured continuously by online mass spectrometry. Sampling was performed at steady state for offline analysis of remaining carbon source, alginate and transcriptome. Detailed sampling protocols can be found in Additional file 4. During the cultivations biomass was measured as OD660 and this was converted to biomass concentration in gDW/L using a conversion of 0.36 g/L OD unit.

Additional file 4. Description of the growth media used for cultivations, and standard operating procedures used in sampling for transcriptome analysis, as well as analysis of alginate produced and remaining carbon source in the chemostat cultures.

Format: DOCX Size: 28KB Download fileOpen Data

Carbon source, alginate and transcriptome analysis

Remaining carbon source in the chemostat growth medium was analyzed by HPLC on a 300x7.8 mm Aminex HPX-87H ion exchange column (BioRad, PA) at 45°C with 0.6 ml/min of 5 mM H2SO4 as the mobile phase. Alginate in the medium was quantified as described previously [11]. Since the alginate quantification assay operates on deacetylated alginate, acetylation had to be determined separately. This was done with the same anion exchange HPLC method that was used for quantification of residual carbon source. The acidic buffer used is sufficient to deacetylate alginate, so acetate can be measured directly.

Transcriptome analysis was done on a custom 385K 60-mer expression microarray (Roche NimbleGen Inc., WI) covering the P. fluorescens SBW25 genome. RNA was isolated with the RNEasy Midi Kit (Qiagen), and when necessary was up-concentrated with Microcon YM 30 spin columns (Millipore, MA). cDNA was produced from isolated RNA according to Roche NimbleGen Inc. instructions, from which hybridization and array scanning was purchased as a service. Analysis of the microarray data was done with GeneSpring GX software, version 11 (Agilent, CA).

Metabolic network reconstruction and analysis

Reconstruction of the draft metabolic network in P. fluorescens SBW25 was based on the recently published annotated genome of the organism [21], and was done in a semi-automated fashion by using the Pathway Tools software suite [39], including the HoleFiller algorithm for closing gaps in the metabolic network. During the first phase of the reconstruction, the software automatically connects the gene products and reactions that can be unambiguously established from the genome annotation and sequence when compared to the existing inventory of genome/pathway databases. For enzyme–reactions associations that have a higher degree of uncertainty, the user is presented with the reactions that are hypothesized to be present in the network and potential enzymes (or, more accurately, their encoding genes) that could catalyse the reaction in question. The accurate assignment is then made based on manual curation. After this curation process is completed, an algorithm is called that identifies 'holes' in the metabolic network. A metabolic hole is a single biochemical reaction that is absent from an otherwise complete pathway, in such a way that filling of the hole yields a functional pathway that can carry a metabolic flux. If candidate gene products for filling the metabolic holes can be identified by the software, these are presented to the user for manual curation. This hole-filling is an iterative process, since introduction of new reactions into the network might justify the introduction of yet new pathways in the model, depending on the manually set cut-off for presence of a given pathway in the model. In the case of the draft model of P. fluorescens SBW25, the manual curation constituted verification of 90 enzyme–reaction connections and assignment of 43 protein complexes. 92 'holes' in the metabolic network were filled by manual curation, distributed as 74, 16 and 2 in the first, second and third iterations of the algorithm, respectively. Manual curation of the draft model was done by literature studies and use of online databases. Literature references used in the manual curation of the draft model are listed in Additional file 5.

Additional file 5. The literature references used in the manual curation of the draft genome-scale metabolic model.

Format: DOCX Size: 331KB Download fileOpen Data

The draft model was translated into the RAVEN Toolbox format [Agren et al., submitted; for overview see [41]] by the use of custom Perl scripts. Concomitantly, a further manual pruning of the model was performed. This included the removal of non-metabolic reactions and reactions with generalized substrates, dereplication of reactions performed by isoenzymes and alternative formulations of reactions as found in Pathway Tools, assignment of reaction irreversibility where applicable and verification of cofactor specificities. Furthermore, sequence and network comparison with the iJN746 and iMO1056 models for P. putida KT2440 and P. aeruginosa PAO1, respectively, allowed for addition of 38 reactions. Also, the pathways in the P. fluorescens SBW25 model defining fatty acid biosynthesis, glycerophospholipid metabolism and peptidoglycan biosynthesis were incomplete in the Pathway Tools formulation, and was manually completed by comparison with the iJN746 model as highly homologous gene products could be found for all reactions.

The final model was designated iSB1139. The model is available for download in both Excel format and in SBML at http://www.sysbio.se/biomet webcite. Flux balance analysis of the SBW25 model was performed with the linear programming solver Mosek (Mosek ApS, Denmark) for Matlab (The Mathworks, MA).

Competing interests

The authors declare that they have no competing interests.

Authors' contributions

SEFB participated in construction of the custom expression array, performed microarray data analysis, contributed to analysis of physiological parameters, constructed the genome-scale metabolic model and performed comparisons with other species, and drafted the manuscript. SB performed the random sampling flux analysis, the calculations about theoretical yields and wrote part of the manuscript. HS and ØJ had major roles in cultivations, while HE was responsible for strain constructions. PB was involved in experimental design. TEE was leading the cultivation activities, JN was leading the modelling parts and SV was project leader for the overall project. All authors were to varying degrees involved in the planning, design and evaluation of the project, and read and approved the final manuscript.

Acknowledgments

This project was funded by the ERA-NET program SysMo. We are grateful to Randi Aune for contributions to cultivations and physiological analyses. Yi-Qian Sun and Marianne Bakke-Nilsen contributed to RNA preparations and some strain constructions. Sunniva Hoel and Anders Øverby contributed to various aspects of the cultivations.

References

  1. Tolker-Nielsen T, Molin S: The biofilm lifestyle of pseudomonads. In Pseudomonas, Volume 1. Edited by Ramos J-L. New York: Kluywer Academic; 2004:547-571. OpenURL

  2. Gómez MI, Prince A: Opportunistic infections in lung disease: Pseudomonas infections in cystic fibrosis.

    Curr Opin Pharmacol 2007, 7(3):244-251. PubMed Abstract | Publisher Full Text OpenURL

  3. Wagner V, Iglewski V: P. aeruginosa biofilms in CF infection.

    Clin Rev Allergy Immunol 2008, 35(3):124-134. PubMed Abstract | Publisher Full Text OpenURL

  4. Govan JR, Harris GS: Pseudomonas aeruginosa and cystic fibrosis: unusual bacterial adaptation and pathogenesis.

    Microbiol Sci 1986, 3(10):302-308. PubMed Abstract OpenURL

  5. Henry RL, Mellis CM, Petrovic L: Mucoid Pseudomonas aeruginosa is a marker of poor survival in cystic fibrosis.

    Pediatr Pulmonol 1992, 12(3):158-161. PubMed Abstract | Publisher Full Text OpenURL

  6. Martin DW, Schurr MJ, Mudd MH, Govan JR, Holloway BW, Deretic V: Mechanism of conversion to mucoidy in Pseudomonas aeruginosa infecting cystic fibrosis patients.

    Proc Natl Acad Sci U S A 1993, 90(18):8377-8381. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  7. Damron FH, Goldberg JB: Proteolytic regulation of alginate overproduction in Pseudomonas aeruginosa.

    Mol Microbiol 2012, 84(4):595-607. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  8. Schurr MJ, Yu H, Martinez-Salazar JM, Boucher JC, Deretic V: Control of AlgU, a member of the sigma E-like family of stress sigma factors, by the negative regulators MucA and MucB and Pseudomonas aeruginosa conversion to mucoidy in cystic fibrosis.

    J Bacteriol 1996, 178(16):4997-5004. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  9. Firoved AM, Deretic V: Microarray analysis of global gene expression in mucoid Pseudomonas aeruginosa.

    J Bacteriol 2003, 185(3):1071-1081. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  10. Behrends V, Ryall B, Wang X, Bundy JG, Williams HD: Metabolic profiling of Pseudomonas aeruginosa demonstrates that the anti-sigma factor MucA modulates osmotic stress tolerance.

    Mol Biosyst 2010, 6(3):562-569. PubMed Abstract | Publisher Full Text OpenURL

  11. Steigedal M, Sletta H, Moreno S, Mærk M, Christensen BE, Bjerkan T, Ellingsen TE, Espìn G, Ertesvåg H, Valla S: The Azotobacter vinelandii AlgE mannuronan C-5-epimerase family is essential for the in vivo control of alginate monomer composition and for functional cyst formation.

    Environ Microbiol 2008, 10(7):1760-1770. PubMed Abstract | Publisher Full Text OpenURL

  12. Draget KI, Skjåk-Bræk G, Smidsrød O: Alginate based new materials.

    Int J Biol Macromol 1997, 21(1–2):47-55. PubMed Abstract | Publisher Full Text OpenURL

  13. Hay ID, Ur Rehman Z, Ghafoor A, Rehm BHA: Bacterial biosynthesis of alginates.

    J Chem Technol Biotechnol 2010, 85(6):752-759. Publisher Full Text OpenURL

  14. Franklin MJ, Nivens DE, Weadge JT, Howell PL: Biosynthesis of the Pseudomonas aeruginosa extracellular Polysaccharides, Alginate, Pel, and Psl.

    Front Microbiol 2011, 2:article 167. OpenURL

  15. Skjåk-Bræk G, Grasdalen H, Larsen B: Monomer sequence and acetylation pattern in some bacterial alginates.

    Carbohydr Res 1986, 154(1):239-250. PubMed Abstract | Publisher Full Text OpenURL

  16. Durot M, Bourguignon P-Y, Schachter V: Genome-scale models of bacterial metabolism: reconstruction and applications.

    FEMS Microbiol Rev 2009, 33(1):164-190. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  17. Oberhardt MA, Palsson BO, Papin JA: Applications of genome-scale metabolic reconstructions.

    Mol Syst Biol 2009, 5:article 320. OpenURL

  18. Antoniewicz MR, Kraynie DF, Laffend LA, González-Lergier J, Kelleher JK, Stephanopoulos G: Metabolic flux analysis in a nonstationary system: Fed-batch fermentation of a high yielding strain of E. coli producing 1,3-propanediol.

    Metab Eng 2007, 9(3):277-292. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  19. Patil KR, Nielsen J: Uncovering transcriptional regulation of metabolism by using metabolic network topology.

    Proc Natl Acad Sci U S A 2005, 102(8):2685-2689. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  20. Kim TY, Kim HU, Park JM, Song H, Kim JS, Lee SY: Genome-scale analysis of Mannheimia succiniciproducens metabolism.

    Biotechnol Bioeng 2007, 97(4):657-671. PubMed Abstract | Publisher Full Text OpenURL

  21. Silby M, Cerdeno-Tarraga A, Vernikos G, Giddens S, Jackson R, Preston G, Zhang X-X, Moon C, Gehrig S, Godfrey S: Genomic and genetic analyses of diversity and plant interactions of Pseudomonas fluorescens.

    Genome Biol 2009, 10(5):R51. PubMed Abstract | BioMed Central Full Text | PubMed Central Full Text OpenURL

  22. Bakkevig K, Sletta H, Gimmestad M, Aune R, Ertesvåg H, Degnes K, Christensen BE, Ellingsen TE, Valla S: Role of the Pseudomonas fluorescens alginate lyase (AlgL) in clearing the periplasm of alginates not exported to the extracellular environment.

    J Bacteriol 2005, 187(24):8375-8384. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  23. Oberhardt MA, Puchalka J, Fryer KE, Martins dos Santos VAP, Papin JA: Genome-scale metabolic network analysis of the opportunistic pathogen Pseudomonas aeruginosa PAO1.

    J Bacteriol 2008, 190(8):2790-2803. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  24. Puchalka J, Oberhardt MA, Godinho M, Bielecka A, Regenhardt D, Timmis KN, Papin JA, Martins dos Santos VAP: Genome-scale reconstruction and analysis of the Pseudomonas putida KT2440 metabolic network facilitates applications in biotechnology.

    PLoS Comput Biol 2008, 4(10):e1000210. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  25. Nogales J, Palsson B, Thiele I: A genome-scale metabolic reconstruction of Pseudomonas putida KT2440: iJN746 as a cell factory.

    BMC Syst Biol 2008, 2(1):79. PubMed Abstract | BioMed Central Full Text | PubMed Central Full Text OpenURL

  26. Pulcrano G, Iula DV, Raia V, Rossano F, Catania MR: Different mutations in mucA gene of Pseudomonas aeruginosa mucoid strains in cystic fibrosis patients and their effect on algU gene expression.

    New Microbiol 2012, 35(3):295-305. PubMed Abstract OpenURL

  27. Coyne MJ, Russell KS, Coyle CL, Goldberg JB: The Pseudomonas aeruginosa algC gene encodes phosphoglucomutase, required for the synthesis of a complete lipopolysaccharide core.

    J Bacteriol 1994, 176(12):3500-3507. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  28. Olvera C, Goldberg JB, Sánchez R, Soberón-Chávez G: The Pseudomonas aeruginosa algC gene product participates in rhamnolipid biosynthesis.

    FEMS Microbiol Lett 1999, 179(1):85-90. PubMed Abstract | Publisher Full Text OpenURL

  29. Paletta J, Ohman D: Evidence for two promoters internal to the alginate biosynthesis operon in Pseudomonas aeruginosa.

    Curr Microbiol 2012, 65(6):770-775. PubMed Abstract | Publisher Full Text OpenURL

  30. Durham DR, Phibbs PV: Fractionation and characterization of the phosphoenolpyruvate: fructose 1-phosphotransferase system from Pseudomonas aeruginosa.

    J Bacteriol 1982, 149(2):534-541. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  31. Schweizer HP, Jump R, Po C: Structure and gene-polypeptide relationships of the region encoding glycerol diffusion facilitator (GlpF) and glycerol kinase (GlpK) of Pseudomonas aeruginosa.

    Microbiology 1997, 143(4):1287-1297. PubMed Abstract | Publisher Full Text OpenURL

  32. Lilley AK, Bailey MJ: The acquisition of indigenous plasmids by a genetically marked pseudomonad population colonizing the sugar beet phytosphere is related to local environmental conditions.

    Appl Environ Microbiol 1997, 63(4):1577-1583. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  33. Lien S, Sletta H, Ellingsen T, Valla S, Correa E, Goodacre R, Vernstad K, Borgos S, Bruheim P: Investigating alginate production and carbon utilization in Pseudomonas fluorescens SBW25 using mass spectrometry-based metabolic profiling.

    Metabolomics 2012. Publisher Full Text OpenURL

  34. Gurney R, Thomas C: Mupirocin: biosynthesis, special features and applications of an antibiotic from a Gram-negative bacterium.

    Appl Microbiol Biotechnol 2011, 90(1):11-21. PubMed Abstract | Publisher Full Text OpenURL

  35. Bangera MG, Thomashow LS: Identification and characterization of a gene cluster for synthesis of the polyketide antibiotic 2,4-diacetylphloroglucinol from Pseudomonas fluorescens Q2-87.

    J Bacteriol 1999, 181(10):3155-3163. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  36. Nowak-Thompson B, Chaney N, Wing JS, Gould SJ, Loper JE: Characterization of the pyoluteorin biosynthetic gene cluster of Pseudomonas fluorescens Pf-5.

    J Bacteriol 1999, 181(7):2166-2174. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  37. Chandrasekaran S, Price ND: Probabilistic integrative modeling of genome-scale metabolic and regulatory networks in Escherichia coli and Mycobacterium tuberculosis.

    Proc Natl Acad Sci 2010, 107(41):17845-17850. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  38. Henry CS, DeJongh M, Best AA, Frybarger PM, Linsay B, Stevens RL: High-throughput generation, optimization and analysis of genome-scale metabolic models.

    Nat Biotechnol 2010, 28(9):977-982. PubMed Abstract | Publisher Full Text OpenURL

  39. Karp PD, Paley S, Romero P: The pathway tools software.

    Bioinformatics 2002, 18(suppl 1):S225-S232. PubMed Abstract | Publisher Full Text OpenURL

  40. Karp PD, Paley SM, Krummenacker M, Latendresse M, Dale JM, Lee TJ, Kaipa P, Gilham F, Spaulding A, Popescu L: Pathway Tools version 13.0: integrated software for pathway/genome informatics and systems biology.

    Brief Bioinform 2010, 11(1):40-79. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  41. Caspeta L, Shoaie S, Agren R, Nookaew I, Nielsen J: Genome-scale metabolic reconstructions of Pichia stipitis and Pichia pastoris and in silico evaluation of their potentials.

    BMC Syst Biol 2012, 6:24. PubMed Abstract | BioMed Central Full Text | PubMed Central Full Text OpenURL

  42. Reed J, Vo T, Schilling C, Palsson B: An expanded genome-scale model of Escherichia coli K-12 (iJR904 GSM/GPR).

    Genome Biol 2003, 4(9):R54. PubMed Abstract | BioMed Central Full Text | PubMed Central Full Text OpenURL

  43. Revelles O, Espinosa-Urgel M, Fuhrer T, Sauer U, Ramos JL: Multiple and interconnected pathways for L-lysine catabolism in Pseudomonas putida KT2440.

    J Bacteriol 2005, 187(21):7500-7510. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  44. Revelles O, Wittich R-M, Ramos JL: Identification of the initial steps in D-lysine catabolism in Pseudomonas putida.

    J Bacteriol 2007, 189(7):2787-2792. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  45. Oberhardt MA, Puchałka J, Martins dos Santos VAP, Papin JA: Reconciliation of genome-scale metabolic reconstructions for comparative systems analysis.

    PLoS Comput Biol 2011, 7(3):e1001116. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  46. Covert MW, Knight EM, Reed JL, Herrgard MJ, Palsson BO: Integrating high-throughput and computational data elucidates bacterial networks.

    Nature 2004, 429(6987):92-96. PubMed Abstract | Publisher Full Text OpenURL

  47. Varma A, Palsson BO: Stoichiometric flux balance models quantitatively predict growth and metabolic by-product secretion in wild-type Escherichia coli W3110.

    Appl Environ Microbiol 1994, 60(10):3724-3731. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  48. Roels JA: Energetics and kinetics in biotechnology / J.A. Roels. Amsterdam; New York: Elsevier Biomedical Press; 1983. OpenURL

  49. Calhoun MW, Oden KL, Gennis RB, de Mattos MJ, Neijssel OM: Energetic efficiency of Escherichia coli: effects of mutations in components of the aerobic respiratory chain.

    J Bacteriol 1993, 175(10):3020-3025. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  50. Alvarez-Ortega C, Harwood CS: Responses of Pseudomonas aeruginosa to low oxygen indicate that growth in the cystic fibrosis lung is by aerobic respiration.

    Mol Microbiol 2007, 65(1):153-165. PubMed Abstract | Publisher Full Text OpenURL

  51. De Vries W, Kapteijn WMC, Van Der Beek EG, Stouthamer AH: Molar growth yields and fermentation balances of Lactobacillus casei L3 in batch cultures and in continuous cultures.

    J Gen Microbiol 1970, 63(3):333-345. PubMed Abstract | Publisher Full Text OpenURL

  52. Gygi SP, Rochon Y, Franza BR, Aebersold R: Correlation between protein and mRNA abundance in yeast.

    Mol Cell Biol 1999, 19(3):1720-1730. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  53. Moxley JF, Jewett MC, Antoniewicz MR, Villas-Boas SG, Alper H, Wheeler RT, Tong L, Hinnebusch AG, Ideker T, Nielsen J: Linking high-resolution metabolic flux phenotypes and transcriptional regulation in yeast modulated by the global regulator Gcn4p.

    Proc Natl Acad Sci 2009, 106(16):6477-6482. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  54. Yang CY, Hua QH, Shimizu KS: Integration of the information from gene expression and metabolic fluxes for the analysis of the regulatory mechanisms in Synechocystis.

    Appl Microbiol Biotechnol 2002, 58(6):813-822. PubMed Abstract | Publisher Full Text OpenURL

  55. Bordel S, Agren R, Nielsen J: Sampling the solution space in genome-scale metabolic networks reveals transcriptional regulation in key enzymes.

    PLoS Comput Biol 2010, 6(7):e1000859. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  56. Portais J-C, Delort A-M: Carbohydrate cycling in micro-organisms: what can 13C-NMR tell us?

    FEMS Microbiol Rev 2002, 26(4):375-402. PubMed Abstract OpenURL

  57. Tannler S, Decasper S, Sauer U: Maintenance metabolism and carbon fluxes in Bacillus species.

    Microb Cell Fact 2008, 7:19. PubMed Abstract | BioMed Central Full Text | PubMed Central Full Text OpenURL

  58. Park SM, Sinskey AJ, Stephanopoulos G: Metabolic and physiological studies of Corynebacterium glutamicum mutants.

    Biotechnol Bioeng 1997, 55(6):864-879. PubMed Abstract | Publisher Full Text OpenURL

  59. Gonzalez-Siso MI, Garcia-Leiro A, Tarrio N, Cerdan ME: Sugar metabolism, redox balance and oxidative stress response in the respiratory yeast Kluyveromyces lactis.

    Microb Cell Fact 2009, 8:46. PubMed Abstract | BioMed Central Full Text | PubMed Central Full Text OpenURL

  60. Sauer U, Canonaco F, Heri S, Perrenoud A, Fischer E: The soluble and membrane-bound transhydrogenases UdhA and PntAB have divergent functions in NADPH metabolism of Escherichia coli.

    J Biol Chem 2004, 279(8):6613-6619. PubMed Abstract | Publisher Full Text OpenURL

  61. Fuhrer T, Sauer U: Different biochemical mechanisms ensure network-wide balancing of reducing equivalents in microbial metabolism.

    J Bacteriol 2009, 191(7):2112-2121. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL

  62. Chavarria M, Kleijn RJ, Sauer U, Pfluger-Grau K, de Lorenzo V: Regulatory tasks of the phosphoenolpyruvate-phosphotransferase system of Pseudomonas putida in central carbon metabolism.

    MBio 2012, 3:2. OpenURL

  63. Sambrook J, Russell D: Molecular cloning: a laboratory manual. Third edition. New York: Cold Spring Harbor Laboratory Press; 2001. OpenURL

  64. Gimmestad M, Sletta H, Ertesvag H, Bakkevig K, Jain S, Suh SJ, Skjak-Braek G, Ellingsen TE, Ohman DE, Valla S: The Pseudomonas fluorescens AlgG protein, but not its mannuronan C-5-epimerase activity, is needed for alginate polymer formation.

    J Bacteriol 2003, 185(12):3515-3523. PubMed Abstract | Publisher Full Text | PubMed Central Full Text OpenURL