Skip to main content
Download PDF
  • Research article
  • Open access
  • Published:

Solid fermentation of wheat bran for hydrolytic enzymes production and saccharification content by a local isolate Bacillus megatherium

BMC Biotechnology volume 14, Article number: 29 (2014) Cite this article

Abstract

Back ground

For enzyme production, the costs of solid state fermentation (SSF) techniques were lower and the production higher than submerged cultures. A large number of fungal species was known to grow well on moist substrates, whereas many bacteria were unable to grow under this condition. Therefore, the aim of this study was to isolate a highly efficient strain of Bacillus sp utilizing wheat bran in SSF and optimizing the enzyme production and soluble carbohydrates.

Results

A local strain Bacillus megatherium was isolated from dung sheep. The maximum production of pectinase, xylanase and α-amylase, and saccharification content (total soluble carbohydrates and reducing sugars) were obtained by application of the B. megatherium in SSF using wheat bran as compared to grasses, palm leaves and date seeds. All enzymes and saccharification content exhibited their maximum production during 12–24 h, at the range of 40–80% moisture content of wheat bran, temperature 37-45°C and pH 5–8. An ascending repression of pectinase production was observed by carbon supplements of lactose, glucose, maltose, sucrose and starch, respectively. All carbon supplements improved the production of xylanase and α-amylase, except of lactose decreased α-amylase production. A little increase in the yield of total reducing sugars was detected for all carbon supplements. Among the nitrogen sources, yeast extract induced a significant repression to all enzyme productivity. Sodium nitrate, urea and ammonium chloride enhanced the production of xylanase, α-amylase and pectinase, respectively. Yeast extract, urea, ammonium sulphate and ammonium chloride enhanced the productivity of reducing sugars.

Conclusions

The optimization of enzyme production and sccharification content by B. megatherium in SSF required only adjustment of incubation period and temperature, moisture content and initial pH. Wheat bran supplied enough nutrients without any need for addition of supplements of carbon and nitrogen sources.

Background

Agricultural residues have an enormous potential as renewable carbon and energy sources. The main potential applications of agricultural residues are in food, animal feed, biofuel and pharmaceutical industries. Saccharification of agricultural residues by microbial hydrolytic enzymes (cellulases, xylanases, amylases and pectinases) is the first step of bioconversion of organic material into reducing sugars, like glucose and xylose [1]. In the saccharification of agricultural residues, a potential effect was detected in presence of two or more enzymes [2]. Cellulases for cellulose hydrolysis [2], xylanases for hemicelluloses hydrolysis [3], amylase for amylose hydrolysis [4] and pectinase for pectin hydrolysis [5] are cooperatively needed in the saccharification of agricultural residues. The reducing sugars obtained from these hydrolyzing actions could be utilized as carbon and energy sources in the fermentation industry, such as lactic acid [6], hydrogen [7] and ethanol [8]. In addition, microbial hydrolytic enzymes utilized in several applications, such as food, textile, paper, pulp and detergent industries [9–12].

Solid state fermentation (SSF) is the growth of organisms on moist substrates in the absence of free-flowing water. The use of SSF for production of enzymes and other products has many advantages over submerged fermentation [13]. These advantages included: easier recovery of products, the absence of foam formation and smaller reactor volumes. Moreover, contamination risks are significantly reduced due to the low water contents and, consequently, the volume of effluents decreases. Another very important advantage is that, it permits the use of agricultural and agro-industrial residues as substrates which are converted into products with high commercial value like secondary metabolites [13, 14]. Furthermore, the utilization of these compounds helps in solving pollution problems, which otherwise cause their disposal [15]. For enzyme production, the costs of these techniques are lower and the production is higher than submerged cultures [16, 17]. A large number of fungal species was known to grow well on moist substrates in the absence of free-flowing water, whereas many bacteria are unable to grow under this condition [18–21]. As a result, most studies involving SSF have been conducted by using fungi. However, there are little reports of bacterial strains being used successfully for the production of enzymes by using SSF [4, 5, 22, 23]. Therefore, the aim of this study is to isolate strain of Bacillus sp. capable of using wheat bran in SSF to produce α-amylase, xylanase and pectinase. The saccharification content, total soluble carbohydrates and reducing sugars, of wheat bran was studied. Studies on optimizing production of enzymes and saccharification content were also carried out.

Methods

Isolation, identification and efficiency of the cellulose decomposing bacilli

Five isolates of Bacillus spp. were isolated from different samples i.e., sheep dung, horses waste, manure compost and rhizosphere soil. The efficiency of the five strains in cellulose decomposion was estimated using caboxymethyl cellulose (CMC) agar medium containing g/l: CMC, 5; peptone, 5; NaCl, 5; beef extract, 3; agar, 18 and pH was adjusted to 7 [24]. The most efficient strain in cellulose decomposion was identified according to Bergey’s Manual of Systematic Bacteriology [25]. The highest efficient strain in cellulose decomposion was isolated from sheep dung and identified as B. megatherium.

Agricultural residues

Four dried agricultural residues, i.e. wheat bran, date seeds, grass and palm leaves were used as substrates for solid state fermentation (SSF).

Physicochemical parameters of SSF

Physicochemical parameters of SSF were studied for optimization production conditions of soluble carbohydrates, reducing sugars, α-amylase, pectinase and xylanase by B. megatherium. The agricultural residues were sperately sterilized in an autoclave for 20 min at 121°C. B. megatherium was grown in 50 ml Erlenmeyer flask included 5 g of the respective sterilized agricultural residue and appropriate amount of water needed to adjust the moisture of dried substrate, which contained 10% moisture after dring. Optimized physicochemical parameters including: incubation period, incubation temperature, and moisture content of the substrate and incubation pH. The pH was adjusted using 0.1 M NaOH or HCl. The influence of supplementation of carbon sources (glucose, maltose, starch, sucrose, and lactose at 1% w/v) and nitrogen sources (yeast extract, urea, sodium nitrate, ammonium sulphate, and ammonium chloride at 1% w/v) has been studied. Each experiment was done in triplicate.

Soluble carbohydrate and enzyme extraction

Soluble carbohydrate and enzyme were extracted by mixing the fermented substrate with 50 ml distilled water and shaked on a rotary shaker at 180 rpm overnight. The suspension was then centrifuged at 12000 rpm for 10 min and the supernatant was designated as a crude extract.

Determination of total reducing sugars

Total reducing sugars were determined by the method of Miller [26]. The reaction mixture contained 0.5 ml of crude extract and 0.5 ml dinitrosalicylic acid reagent. The tubes were heated in a boiling water bath for 10 min. After cooling to room temperature, the absorbance was measured at 560 nm. Glucose served as the calibration standard for total reducing sugar determination.

Determination of total soluble carbohydrates

Total soluble carbohydrates were determined by the method of Dubois et al. [27]. The reaction mixture contained 25 μl of a 4:1 mixture of phenol and water, 0.8 ml of crude extract and 2 ml of concentrated sulfuric acid. Then mixed well, and heated in a boiling water bath for 30 min. The absorbance was determined at 480 nm. Glucose served as the calibration standard for total carbohydrate determination.

Enzymes assays

α-Amylase, pectinase and xylanase activities were assayed by determining the liberated reducing end products using maltose, galacturonic acid and xylose as standards, respectively [26]. Substrates used were starch, polygalacturonic acid and birchwood xylan for α-amylase, pectinase and xylanase, respectively. The reaction mixture (0.5 ml) contained 1% substrate, 0.05 M sodium acetate buffer pH 5.5 and 0.1 ml crude extract. Assays were carried out at 37°C for 1 h. Then 0.5 ml dinitrosalicylic acid reagent was added to each tube. Then the reaction mixture was mixed well, and heated in a boiling water bath for 10 min. After cooling to room temperature, the absorbance was measured at 560 nm. One unit of enzyme activity is defined as the amount of enzyme which liberated one μmol of reducing sugar per min under standard assay conditions.

All the experimental work was run in triplicates.

Statistical analysis

The obtained data were statistically analyzed as a randomized complete block design with three replicates by analysis of variance (ANOVA) using the statistical package software SAS (SAS Institute Inc., 2000, Cary, NC., USA). Comparisons between means were made by F-test and the least significant differences (LSD) at level P = 0.05. Correlations coefficient among the different parameters were also calculated by SAS.

Results and discussion

The effect of agricultural residues

Production of pectinase, xylanase and α-amylase, and saccharification content (total soluble carbohydrates and reducing sugars) by B. megatherium were tested in different SSF sources using wheat bran, grasses, palm leaves and date seeds. Figure 1a showed the maximum production of pectinase, xylanase and α-amylase by B. megatherium (350, 150 and 100 units/g solid, respectively) in SSF using wheat bran as compared to other agriculture residues. The saccharification content of these agricultural residues improved these results, whereas the productivity of total soluble carbohydrates and reducing sugars exhibited maximum production by using wheat bran (Figure 1b). Similarly, among the lignocellulosic substrates tested, wheat bran gave maximum yield of xylanase by Cellulosimicrobium sp. as compared to other substrates viz. gram bran, rice husk, rice bran, wood dust and apple pomace [28]. The best substrate for xylanase production was wheat bran due to its nutritional content and large surface area [29], where wheat bran contained xylan and protein, which were served as carbon and nitrogen sources for microorganisms, respectively [30]. α-Amylase was also exhibited the maximum production by Clostridium thermosulforegenes using wheat bran [31]. Wheat bran characterized by its better air circulation, loose particle binding and efficient penetration by mycelia and cheaper, therefore it showed a better prospect economically in fermentation processes [32]. Therefore, physicochemical parameters of SSF using wheat bran for optimization production of enzymes and saccharification content of B. megatherium was performed in the following study.

Figure 1
figure 1

Effect of different agriculture wastes on the production of pectinase, xylanase and α-amylase (a) and total carbohydrate and reducing sugars (b) by B. megatherium in SSF. Process conditions: incubation time 48 h., initial moisture content 50% (by volume per mass) and temperature at 37°C.

Full size image

The effect of incubation period

Figure 2a showed the effect of incubation period on production of pectinase, α-amylase and xylanase by B. megatherium grown on wheat bran in SSF. Pectinase, α-amylase and xylanase exhibited their maximum production after 24 h (720, 220 and 280 units/g solid, respectively). The maximum production of total soluble carbohydrates (160 mg/g solid) and reducing sugars (55 mg/g solid) was detected after 12 and 24 h, respectively (Figure 2b). The maximum production of reducing sugars was inagreement with the maximum production of enzymes. Similarly, the maximum activity of α-amylase was noted in enzyme extracts harvested after 24 h of SSF B. subtilis[33]. The formation of xylanase started from 18 h and reached its maximum after 72 h by Bacillus sp. [34]. B. licheniformis produced maximum of pectinase after 48 h [5].

Figure 2
figure 2

Effect of incubation time on the production of pectinase, xylanase and α-amylase (a), and total carbohydrate and reducing sugars (b) by B. megatherium in SSF using wheat bran as substrate. Process conditions: initial moisture content 50% (by volume per mass) and temperature at 37°C.

Full size image

The effect of initial moisture content

In SSF, the moisture content is an important factor that influences the growth and product yield of microbes [35]. Moisture is reported to cause swelling of the substrates, thereby facilitating better utilization of the substrate by microorganisms [36, 37]. The data presented in t Figure 3a, clearly indicated a maximum production of the enzymes pectinase (720 units/g solid), xylanase (310 units/g solid) and α-amylase (115 units/g solid) by B. megatherium at 40, 80 and 70% moisture, respectively. In addition, the maximum saccharification content of total soluble carbohydrates (140 mg/g solid) and reducing sugars (55 mg/g solid) was observed at 70 and 80% moisture, respectively (Figure 3b). Other results showed that the yield of α-amylase and amylopullulanase by Clostridium thermosulfurogenes increased with an increase in solid to moistening agent ratio from 1:0.5 to 1:2.5 (30 to 75%) with a maximum at 1:2.25 (73%) [31]. Optimum xylanase production from Bacillus sp. PKD-9 was observed when wheat bran was used at 1:4 ratio of solid substrate-to-moisture [23]. Any further increase in the ratio resulted in the decrease of enzyme yields may be due to clumping of solid particles which results in the decrease of interparticle space and diffusion of nutrients [29, 37]. In contrast, the low moisture content leads to the decreased solubility of nutrients present in the wheat bran thereby decreased enzyme yields [38].

Figure 3
figure 3

Effect of moisture % on the production of pectinase, xylanase and α-amylase (a), and total carbohydrate and reducing sugars (b) by B. megatherium in SSF using wheat bran as substrate. Process conditions: incubation times 48 h and temperature at 37°C.

Full size image

The effect of incubation temperature

The usual temperature maintained in SSF systems is in the range of 25-32°C, depending on the growth kinetics of microorganism employed for fermentation purposes [39]. In the present study, the maximum production of both pectinase (620 units/g solid) and xylanase (220 units/g solid) by B. megatherium was achieved at 37°C, and 45°C for α-amylase (220 units/g solid) (Figure 4a). These results were confirmed by maximum saccharification content of reducing sugars (54 mg/g solid) at 37°C, where the maximum of total soluble carbohydrates (160 mg/g solid) was detected at 25°C (Figure 4b). In other study, the optimum temperature recorded for maximum growth and α-amylase production by B. subtilis was 35°C [33]. Maximum production of pectinase and xylanase were obtained by B. licheniformis[5] and Bacillus sp. PKD-9 [23] at 37°C in solid wheat bran.

Figure 4
figure 4

Effect of incubation temperature on the production of pectinase, xylanase and α-amylase (a), and total carbohydrate and reducing sugars (b) by B. megatherium in SSF using wheat bran as substrate. Process conditions: incubation times 48 h and initial moisture content 50% (by volume per mass).

Full size image

The effect of pH

The initial pH of fermentation medium has a significant effect on bacterial growth and enzyme production [40]. In order to study the effect of pH on enzyme production and saccharification content of wheat bran by B. megatherium, the production medium having pH's ranged from 4 to 8. Figure 5a shows a maximum production of pectinase (750 units/g solid), xylanase (280 units/g solid) and α-amylase (250 units/g solid) by B. megatherium at pH 7, 6 and 5, respectively. The high activity of pectinase results was reinforced by maximum saccharification content of total soluble carbohydrates (170 mg/g solid) and reducing sugars (50 mg/g solid) and at pH 7–8 (Figure 5b). However, most of Bacillus species were found to be produce maximum pectinase at different pH's ranging from 7 to 9 [41]. Further, the type of buffer used in nutrient solution is a key factor in governing α-amylase production by the B. subtilis.

Figure 5
figure 5

Effect of pH on the production of pectinase, xylanase and α-amylase (a), and total carbohydrate and reducing sugars (b) by B. megatherium in SSF using wheat bran as substrates. Process conditions: incubation times 48 h, initial moisture content 50% (by volume per mass) and temperature at 37°C.

Full size image

The effect of supplementation carbon and nitrogen sources

The influence of supplementary carbon sources such as starch, sucrose, maltose, lactose or glucose at 1% (by mass) to wheat bran on production of pectinase, xylanase and α-amylase by B. megatherium was studied (Figure 6a). An ascending inhibition of pectinase production by lactose, glucose, maltose, sucrose and starch was detected, respectively. However, all carbon supplements improved the production of xylanase and α-amylase, except of lactose decreased α-amylase production. While most of carbon supplements exhibited repressive effect on the production of total soluble carbohydrates except of sucrose, a little increase in the yield of total reducing sugars was detected (Figure 6b). The same carbon supplements except starch caused repressive effect on pectinase production by B. licchenformis[5]. Supplementation of carbon sources increased α-amylase production by B. cereus during SSF using wheat bran [22]. B. thermooleovorans is reported to prefer starch, glucose, lactose, maltose and maltodextrins as carbon sources for α-amylase secretion [42, 43]. In contrast, carbon sources such as glucose, maltose and starch did not enhance α-amylase production by thermophilic B. coagulans in solid-state fermentation using wheat bran [29]. Xylanase production by Bacillus sp. AR-009 grown on wheat bran was repressed upon addition of lactose, glucose and sucrose [3].

Figure 6
figure 6

Effect of carbon source (1%) supplementation on the production of pectinase, xylanase and α-amylase (a), and total carbohydrate and reducing sugars (b) by B. megatherium in SSF using wheat bran as substrates.

Full size image

Studies on supplementation of nitrogen sources such as ammonium sulphate, ammonium nitrate, ammonium chloride, yeast extract or urea at 1% concentration to the wheat bran showed various effects on pectinase, xylanase and amylase production by B. megatherium (Figure 7a). Among the nitrogen sources, yeast extract induced a significant repression to all enzyme productivity. While sodium nitrate inhibited α-amylase production from 123 to103 units/g, it enhanced xylanase production from 216 to 355 units/g. Urea on the other hand inhibited production of xylanase and enhanced α-amylase. Also, a significant enhancement of pectinase activity was obtained by ammonium chloride supplementation from 496 to 610 units/g. While all nitrogen sources inhibited the production of total soluble carbohydrates, yeast extract, urea, ammonium sulphate and ammonium chloride enhanced the productivity of the total reducing sugars (Figure 7b). Hashemi et al. [4] reported that ammonium nitrate was the best inducer for α-amylase secretion followed by yeast extract ‘by Bacillus sp. On the other hand, the limitation or starvation of nitrogen during the fermentation resulted in the limited growth of B. subtilis and the enhancement of α-amylase production [44]. For Bacillus sp. AR-009, yeast extract increased xylanase production [3]. Maximum production of pectinase was achieved when yeast extract was used in fermentation medium [5].

Figure 7
figure 7

Effect of nitrogen source (1%) supplementation on the production of pectinase, xylanase and α-amylase (a), and total carbohydrate and reducing sugars (b) by B. megatherium in SSF using wheat bran as substrates. Process conditions: incubation times 48 h, initial moisture content 50% (by volume per mass) at temperatures 37°C.

Full size image

Conclusions

In conclusion, the production of pectinase, xylanase and amylase and saccharification content (total soluble carbohydrates and reducing sugars) by a newly local isolat B. megatherium using wheat bran in SSF will have several advantages. The optimization of enzyme production and sccharification content required only adjustment of incubation time and temperature, moisture content and initial pH. Wheat bran supplied enough nutrients without any need for addition of supplements of carbon and nitrogen sources. All these combined together could greatly reduce the overall cost of production of enzymes and saccharification content by B. megatherium. In the future, the reducing sugars will be used for hydrogen production.

References

  1. Howard RL, Abotsi E, Jansen van REL, Howard S: Lignocellulose biotechnology: issues of bioconversion and enzyme production. Afric J Biotechnol. 2003, 2: 602-619.

    Article  CAS  Google Scholar 

  2. Mansfield SD, Mooney C, Saddler JN: Substrate and enzyme characteristics that limit cellulose hydrolysis. Biotechnol Prog. 1999, 15: 804-816. 10.1021/bp9900864.

    Article  CAS  Google Scholar 

  3. Gessesse A, Mamo G: High level xylanase production by an alkalophilic Bacillus sp. by using solid state fermentation. Enzyme Microb Technol. 1999, 25: 68-72. 10.1016/S0141-0229(99)00006-X.

    Article  CAS  Google Scholar 

  4. Hashemi M, Razavi SH, Shojaosadati SA, Mousavi SM, Khajeh K, Safari M: Development of a solid-state fermentation process for production of an alpha amylase with potentially interesting properties. J Biosci Bioeng. 2010, 110: 333-337. 10.1016/j.jbiosc.2010.03.005.

    Article  CAS  Google Scholar 

  5. Ur Rehman H, Qader SAU, Aman A: Polygalacturonase: production of pectin depolymerising enzyme from bacillus licheniformis KIBGE IB-21. Carbohydr Polym. 2012, 90: 387-391. 10.1016/j.carbpol.2012.05.055.

    Article  Google Scholar 

  6. Anuradha R, Suresh AK, Venkatesh KV: Simultaneous saccharification and fermentation of starch to lactic acid. Process Biochem. 1999, 35: 367-375. 10.1016/S0032-9592(99)00080-1.

    Article  CAS  Google Scholar 

  7. Kapdan IK, Kargi F: Review biohydrogen production from waste materials. Enzyme Microb Technol. 2006, 38: 569-582. 10.1016/j.enzmictec.2005.09.015.

    Article  CAS  Google Scholar 

  8. Sun Y, Cheng J: Hydrolysis of lignocellulosic materials for ethanol production: A review. Bioresour Technol. 2002, 83: 1-11. 10.1016/S0960-8524(01)00212-7.

    Article  CAS  Google Scholar 

  9. Bhat MK, Bhat S: Cellulose degrading enzymes and their potential industrial applications. Biotechnol Adv. 1997, 15: 583-620. 10.1016/S0734-9750(97)00006-2.

    Article  CAS  Google Scholar 

  10. Beg QK, Kapoor M, Mahajan L, Hoondal GS: Microbial xylanases and their industrial applications: a review. Appl Microbiol Biotechnol. 2001, 56: 326-338. 10.1007/s002530100704.

    Article  CAS  Google Scholar 

  11. Hoondal GS, Tiwari RP, Tiwari R, Dahiya N, Beg QK: Microbial alkaline pectinases and their industrial application: A review. Appl Microbiol Biotechnol. 2002, 59: 409-418. 10.1007/s00253-002-1061-1.

    Article  CAS  Google Scholar 

  12. Sivaramakrishnan S, Gangadharan D, Nampoothiri KM, Soccol CR, Pandey A: Alpha-amylases from microbial sources—an overview on recent development. Food Technol Biotechnol. 2006, 44: 173-184.

    CAS  Google Scholar 

  13. Lonsane BK, Ramesh MV: Production of bacterial thermostable α-amylase by solid-state fermentation: a potential tool for achieving economy in enzyme production and starch hydrolysis. Adv Appl Microbiol. 1990, 35: 1-56.

    Article  CAS  Google Scholar 

  14. Pandey A: Recent process developments in solid-state fermentation. Process Biochem. 1992, 27: 109-117. 10.1016/0032-9592(92)80017-W.

    Article  CAS  Google Scholar 

  15. Couto SR, Sanroman MA: Application of solid-state fermentation to food industry – a review. J Food Eng. 2005, 22: 211-219.

    Google Scholar 

  16. Pandey A: Aspects of fermenter design for solid-state fermentations. Process Biochem. 1991, 26: 355-361. 10.1016/0032-9592(91)85026-K.

    Article  CAS  Google Scholar 

  17. Sukumaran RK, Singhania RR, Mathew GM, Pandey A: Cellulase production using biomass feed stock and its application in lignocellulose saccharification for bio-ethanol production. Renew Energ. 2009, 34: 421-424. 10.1016/j.renene.2008.05.008.

    Article  CAS  Google Scholar 

  18. Mohamed SA, Al-MalkiL AL, Khan JA, Kabli SA, Al-Garni SM: Solid state production of polygalacturonase and xylanase by Trichoderma species using cantaloupe and watermelon rinds. J Microbiol. 2013, 51: 605-611. 10.1007/s12275-013-3016-x.

    Article  CAS  Google Scholar 

  19. Rahardjo YSP, Sie S, Weber FJ, Tramper J, Rinzema A: Effect of low oxygen concentrations on growth and α-amyase production of Aspergillus oryzae in model solid-state fermentation systems. Biomol Eng. 2005, 21: 163-172. 10.1016/j.bioeng.2005.01.001.

    Article  CAS  Google Scholar 

  20. Ustok FI, Canan Tari C, Gogus N: Solid-state production of polygalacturonase by Aspergillus sojae ATCC 20235. J Biotechnol. 2007, 127: 322-334. 10.1016/j.jbiotec.2006.07.010.

    Article  CAS  Google Scholar 

  21. Senthilkumar SR, Ashokkumar B, Raj KC, Gunasekaran P: Optimization of medium composition for alkali-stable xylanase production by Aspergillus fischeri Fxn 1 in solid-state fermentation using central composite rotary design. Bioresour Technol. 2005, 96: 1380-1386. 10.1016/j.biortech.2004.11.005.

    Article  CAS  Google Scholar 

  22. Singh RK, Mishra SK, Kumar N: Optimization of α-amylase production on agriculture byproduct by Bacillus cereus MTCC 1305 using solid state fermentation. Res J Pharm Biol Chem Sci. 2010, 1: 867-876.

    CAS  Google Scholar 

  23. Panwar D, Srivastava PK, Kapoor M: Production, extraction and characterization of alkaline xylanase from Bacillus sp. PKD-9 with potential for poultry feed. Biocatal Agric Biotechnol. 2014, 3: 118-125.

    Google Scholar 

  24. Teather RM, Wood PJ: Use of congo red-polysaccharide interactions in enumeration and characterization of cellulytic bacteria from the bovine rumen. Appl Environ Microbiol. 1982, 43: 777-780.

    CAS  Google Scholar 

  25. Bergey JG, Holt NR, Krieg PHA: Lippincott Williams. Bergey’s Manual of Determinative Bacteriology. 1994, 9, ISBN 0-683-00603-7

    Google Scholar 

  26. Miller GL: Use of dinitrosalicylic acid reagent for determination of reducing sugar. Anal Chem. 1959, 31: 426-429. 10.1021/ac60147a030.

    Article  CAS  Google Scholar 

  27. Dubois M, Gilles KA, Hamitton JK, Rebers PA, Smith F: Colorimeteric method for determination of sugars and related substances. Anal Chem. 1956, 28: 350-356. 10.1021/ac60111a017.

    Article  CAS  Google Scholar 

  28. Rajashri DK, Anandrao RJ: Optimization and scale up of cellulase-free xylanase production in solid state fermentation on wheat bran by Cellulosimicrobium sp. MTCC 10645. Jordan J Biol Sci. 2012, 5: 289-294.

    Google Scholar 

  29. Babu KR, Satyanarayana T: α-Amylase production by thermophilic Bacillus coagulans in solid-state fermentation. Process Biochem. 1995, 30: 305-309. 10.1016/0032-9592(95)87038-5.

    Article  CAS  Google Scholar 

  30. Thiago LR, Kellaway RC: Botanical composition and extent of lignification affecting digestibility of wheat and oat straw and pastalum hay. Animal Feed Sci Technol. 1982, 7: 71-81. 10.1016/0377-8401(82)90038-4.

    Article  Google Scholar 

  31. Mrudula S, Reddy G, Seenayya G: Effect of substrate and culture conditions on the production of amylase and pullulanase by thermophilic Clostridium thermosulforegenes SVM17 in solid state fermentation. Malays J Microbiol. 2011, 7: 19-25.

    CAS  Google Scholar 

  32. Malathi S, Chakraborti R: Productions of alkaline protease by a new Aspergillus flavus isolate under solid sustrate fermentation conditions for use as a depilation agent. Appl Environ Microbiol. 1991, 57: 712-716.

    CAS  Google Scholar 

  33. Unakal C, Kallur RI, Kaliwal BB: Production of α-amylase using banana waste by Bacillus subtilis under solid state fermentation. Eur J Exper Biol. 2012, 2: 1044-1052.

    CAS  Google Scholar 

  34. Cordeiro CAM, Martins MLL, Luciano AB, da Silva RF: Production and properties of xylanase from Thermophilic Bacillus sp. Braz Arch Biol Technol. 2002, 45: 413-418. 10.1590/S1516-89132002000600002.

    Article  CAS  Google Scholar 

  35. Ramesh MV, Lonsane BK: Critical importance of moisture content of the medium in α-amylase by Bacillus licheniformis M27 in a solid-state fermentation system. Appl Microbiol Biotechnol. 1990, 33: 501-505.

    Article  CAS  Google Scholar 

  36. Kim JH, Hosobuchi M, Kishimoto M, Seki T, Ryu DDY: Cellulase production by a solidstate culture system. Biotechnol Bioeng. 1985, 27: 1445-1450. 10.1002/bit.260271008.

    Article  CAS  Google Scholar 

  37. Nagendra PG, Chandrasekharan M: L-glutaminase production by marine Vibrio costicola under solid-state fermentation using different substrates. J Marine Biotechnol. 1996, 4: 176-179.

    Google Scholar 

  38. Feniksova RV, Tikhomirova AS, Rakhleeva BE: Conditions for forming amylase and proteinase in surface culture of Bacillus subtilis. Mikrobiologia. 1960, 29: 745-748.

    CAS  Google Scholar 

  39. Lonsane BK, Ghildyal NP, Budiatman S, Ramakrishna SV: Engineering aspects of solid state fermentation. Enzyme Microb Technol. 1985, 7: 258-265. 10.1016/0141-0229(85)90083-3.

    Article  CAS  Google Scholar 

  40. Murad HA, Saleem MME: Utilization of uf-permeate for producing exopolysaccharides from lactic acid bacteria. Mansoura Univ J Agric Sci. 2001, 26: 2167-2175.

    Google Scholar 

  41. Kobayashi T, Koike K, Yoshimatsu T, Higaki N, Suzumatsu A, Ozawa T, Hatada Y, Ito S: Purification and properties of a low-molecular weight, high-alkalinepectate lyase from an alkaliphilic strain of Bacillus. Biosci Biotechnol Biochem. 1999, 63: 65-72. 10.1271/bbb.63.65.

    Article  CAS  Google Scholar 

  42. Narang S, Satyanarayana T: Thermostable α-amylase production by an extreme thermophilic Bacillus thermooleovorans. Lett Appl Microbiol. 2001, 32: 1-35.

    Article  Google Scholar 

  43. Arunava B, Pal SC, Sen SK: Alpha amylase production in lactose medium by Bacillus circulanse. J Microbiol. 1993, 9: 142-148.

    Google Scholar 

  44. Mirminachi F, Zhang A, Roehr M: Citric acid fermentation and heavy metal ions: Effect of iron, manganese and copper. Acta Biotechnol. 2000, 22: 363-373.

    Article  Google Scholar 

Download references

Acknowledgement

This Project was funded by the King Abdulaziz City for Science and Technology (KACST) under grant number 11-ENE1527-03. The authors, therefore, acknowledge with thanks KACST for support for Scientific Research. Also, the authors are appreciating the kind cooperation provided by the Deanship of Scientific Research (DSR), King Abdulaziz University.

Author information

Authors and Affiliations

  1. Chemistry Department, Faculty of Science, King Abdulaziz University, P.O. Box 80203, Jeddah, 21589, Saudi Arabia

    Reda M El-Shishtawy & Abdullah M Asiri

  2. Biochemistry Department, Faculty of Science, King Abdulaziz University, Jeddah, Kingdom of Saudi Arabia

    Saleh A Mohamed, Ibrahim H Ibrahim & Hasan A Al-Talhi

  3. The Center of Excellence for Advanced Materials Research, King Abdulaziz University, Jeddah, 21589, Saudi Arabia

    Abdullah M Asiri

  4. Biology Department, Faculty of Science, King Abdulaziz University, Jeddah, Kingdom of Saudi Arabia

    Abu-bakr M Gomaa

Authors
  1. Reda M El-Shishtawy
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Saleh A Mohamed
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Abdullah M Asiri
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Abu-bakr M Gomaa
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Ibrahim H Ibrahim
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Hasan A Al-Talhi
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Reda M El-Shishtawy or Saleh A Mohamed.

Additional information

Competing interests

The authors declare that they have no competing interests.

Authors’ contributions

El-R, MS, AA, GM, II and AL-H performed all experiments and read and approved the final manuscript.

Authors’ original submitted files for images

Rights and permissions

This article is published under license to BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly credited. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

El-Shishtawy, R.M., Mohamed, S.A., Asiri, A.M. et al. Solid fermentation of wheat bran for hydrolytic enzymes production and saccharification content by a local isolate Bacillus megatherium. BMC Biotechnol 14, 29 (2014). https://doi.org/10.1186/1472-6750-14-29

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/1472-6750-14-29

Keywords

BMC Biotechnology

ISSN: 1472-6750

Contact us